Tag Archives: stem work

Repairing a Bite Mark on a Kirsten Stem


In one of my EBay bargain basket purchases I picked up a Kirsten Barrel and stem. It is complete minus the bowl. I have a bowl coming from a friend so it was time to do some work on the stem and barrel. The valve on the end of the stem was stuck shut so removed the stem and needle valve system from the barrel and filled the barrel with alcohol up to the top of the valve on the end. This worked through the buildup on the valve and I was able to remove it. The barrel was fairly easy to clean up with alcohol and cotton swabs. The stem valve also cleaned up nicely but the stem was another matter altogether.

ImageImage

On the underside of the stem was a deep bite mark. It was rough around the edges and the vulcanite was compromised. On the top side of the stem were some smaller and less deep bite marks that were more like dents. There was also a wrinkle in the topside of the stem that was strange. The first two photos below show the stem when I began to work on it.

ImageImage

I decided to use my heat gun and set it on the lowest setting and held the stem over the gun to lift the tooth marks as much as possible. The ones on the top side of the stem lifted very easily with the heat. The wrinkle also smoothed out easily with the heat. The bite mark on the underside lifted slightly but it was not going to come out smoothly. I then sanded it with 240 grit sandpaper to remove the remnants of the bite marks and remaining tooth chatter. The top of the stem came out very nicely and I would need to work out the scratches with higher grits of sandpaper and micromesh. The underside was another matter. I sanded out the roughness around the edges of the crater in the stem. I sanded out the remnants of tooth chatter to see what I would have to do to reclaim the stem. The next two photos show the stem after the sanding with the 240 and 320 grit sandpaper. The topside is nice, but the bottom crater remains – smaller but visible.

ImageImage

I sanded the stem with 400 and 600 grit wet dry sandpaper to remove the majority of the scratches pictured above. The top side I then sanded with 1500-2400 grit micromesh sanding pads. The first photo below shows the top of the stem and the bite marks and tooth chatter is gone. The stem from the top looks clean and new – ready for the bowl when it gets here. The second photo shows the underside of the stem. For the crater in the underside I cleaned out the hole with a cotton swab and alcohol. I picked away any debris that had collected in the hole with a dental pick. I then filled the hole with black superglue. I made a superglue bubble over the hole to make sure that when it dried it would be able to be full enough. I set it aside for the night. In the morning I sanded it with 320 grit sandpaper and took the bubble down to the surface of the stem. I then sanded with 400 and 600 wet dry to smooth it out more. Finally I sanded it with the 1500-2400 micromesh sanding pads to get it to the point shown in the second photo below.

ImageImage

At this point the stem is repaired and all that remains is to do some final sanding with the higher grits of micromesh sanding pads. I worked on it with 3200 and 3600 grit micromesh and then polished it Maguiar’s. After that I sanded it with 4000-12,000 grit micromesh and then gave it a coat of Obsidian Oil. The finished stem was buffed with White Diamond and then more carnauba wax. I also hand polished the barrel with carnauba wax.

ImageImage

 

No Rounded Shoulders – Keeping Sharp Edges on a Pipe Stem


One of my pet peeves in the realm of refurbished estate pipes is rounded shoulders on the tenon end of the pipe stem where it meets the shank of a pipe. A second one that is nearly as irritating is rounded edges on the button to the point where it has lost all definition. When the pipe was finished and left the factory the transition between the shank and stem was smooth. The edge of the stem was sharp and crisp and the joint was unnoticeable to the touch. I have gotten pickier now in my choice of estates. I would rather pick up a pipe that is in rough shape and needs work than one that has rounded shoulders. Early in my refurbishing days I did not pay attention to this and was guilty of rounding the shoulders. Even in some of the pipes that I have carved in years past I rounded the shoulders through carelessly sanding the stem while it was off of the pipe. Over the years through the helpful critiques of others I have come to see the error and am now very careful in proceeding with stem refurbishing. I decided to write about the error itself and its causes in order to help others avoid this mistake. There are multiple ways to cause the rounding of shoulders and buttons. I want to write about the ones I am guilty of and how I have corrected the errors.

One of the most frequent errors is to over buff the pipe stem to bring it back to black. While the oxidation is removed and the stem shines, the edges are lost. The crisp sharp lines of the pipe are destroyed. I remember working the stems against the buffing wheel with brown and red Tripoli to get rid of the oxidation. I buffed almost indiscriminately on my quest to remove the greenish brown. The sad thing was I also rounded edges, button and sharp angles. I remember buffing stems without the pipe attached and when they were good and black, buffing them with carnauba. They sure shone but the pristine angles were forever gone.

Once the error of buffing the oxidation away and losing the shape of the pipe stem had been pointed out to me I began to search for new ways of removing the oxidation without damaging the edges of the stem and button. My quest took me to the second method that I used – to sand the stem with varying grits of sandpaper. At first glance, this method seemed better than buffing as it was easier to maintain the edges. On another level, however, it was just as bad in that it changed the shape of the stem. Again, I learned the hard way, thinking I could maintain the sharp edges; I sanded the stem while it was removed from the pipe. This stemmed from my fear of damaging the finish and shape of the shank. In doing this my track record was better and over 50% of the stems retained sharp edges. I was better in maintaining the integrity of the button and its edges with this method. But because I knew better than to damage the edges I looked for a different method that would minimize damage to the stem even more.

My third experiment in removing oxidation involved bleaching the stem.  I filled a container with bleach and placed the stem in it for a soak. I tried straight undiluted bleach and bleach diluted 50% with water. I left them in for short periods of time in both solutions. I found that it left the stem surface pitted and rough. It also affected the clean and sharp lines because the pits would also end up on the sharp edges. The only way I knew of removing the pitting and attaining a smooth finish afterward was by sanding with wet dry sand paper from 400-1200 grit. While this was more satisfactory in maintaining sharp and distinct as opposed to rounded shoulders it still was not exactly what I was looking for as it affected the finished look of the stem. Sanding the stem after bleaching still changed the overall profile. So the search went on.

My fourth experiment involved soaking the stems in an Oxyclean solution. I had heard from a variety of people that this worked well and did not leave the stem pitted and rough when it was removed from the soak. I mixed the Oxyclean according to directions – a half scoop for a quart jar of warm water. I shook the jar to dissolve the Oxyclean and then placed the stems in the solution. I experimented with the time left in the solution – anywhere from 1-12 hours. Regardless of the amount of time left in the solution I found that the Oxyclean did not remove the oxidation but did soften it significantly. I learned from my experiments that it took over an hour of soaking to soften the oxidation. The longer soak did not significantly soften the oxidation more. When the stems were removed they were almost white from the work of the solution. I wiped them down with a cotton cloth to remove the surface oxidation that was on the surface and had been softened. I scrubbed it hard with the cloth and was able to remove a lot of the oxidation. However, there was still a remnant that had to be scrubbed or sanded. It is important to note that was less sanding of the stem involved with this method.

A fifth experiment happened accidentally. A friend of mine who does refurbishing as well was using the flame from a Bic lighter to lift tooth marks from a vulcanite stem. He found that the moving flame not only lifted the tooth marks but burned the oxidation. He tried moving the flame quickly over the length of the stem and it worked quite nicely. Many have wondered about heat damage and stems straightening from the heat but miss the point that the flame does not sit anywhere on the stem too long. The concept is to let the flame lick the surface of the stem and quickly paint the stem with the flame. I have experimented with this and found that it works very well in the crease along the button and on heavily oxidized stems. I have also used it after a pipe stem has soaked in Oxyclean and it works. To me the jury is still out on the long term effects of the method but it does work and does not damage the sharp edges or the profile of the stem. The two of us have done a lot of experimenting and talking through the process and continue to learn as we do it. I know others on the blog have experimented with the method as well and have had a variety of experiences with it.

Today, through my experimenting, I arrived at the point where I have combined several of the methods from my learning process described above. I use the Oxyclean soak and the micromesh sanding pads from 1500-12,000 grit to wet sand and dry sand the stems. I like the fact that they do not remove large amounts of material in the process of sanding the stem. Less frequently I have to use 320 grit or 400 grit wet dry sandpaper to work on heavy oxidation. That combination allows me to clean up the stem with minimal invasive action on the surface of the stem. I have added the use a plastic polish between the various grits of micromesh to further clean the stem. I do not finish the stem with the plastic polish but merely use it in the midst of the process. Finally for the tough areas I have used the Bic lighter to quickly move over areas that are hard to sand with the micromesh. With this combination of resources I am happy with the results I am getting on the stems.

But, as always I am on the lookout and thinking of new tools or items that will make my job easier in the cleanup and refurbishing process. Some of my methods or ideas come through odd associations and a passing thought. I was looking at my drill bit keeper the other evening and noticing that the larger bit slots would work well as mortises for the tenons of the stems I was working on. My newest idea is in the design stages. But it is pretty simple. I want to cut a series of 4-5 inch lengths of 1 inch to 1 and ½ inch dowel. I want the doweling to be large enough that I can hold it in my hand while working on the stem or anchor it in a vice.I plan on drilling mortises for the standard tenon sizes into the ends (a different size on each end) of the dowel to accommodate the tenons while I work on the area of the joint of the stem and the shank. At least in theory it will give me a flat edge to push the stem against and allow me to work on the area of the stem that sits against the shank. I have not had time to hunt down some doweling yet but I have been using an ebony block that I have here to the same purpose. I drilled two mortises in the block that can accommodate two different tenon sizes. I also drilled them deep enough to allow the stem to sit flush against the block. I have used it now on two stem cleanups and it works really well. The only drawback that I find is the size of the block. I think the dowel will work better as I can hold it easily in my hand while I am working on the stem.I have included a few pictures of the block that I am currently using with two different styles and sizes of stems. Both stems fit well and the fit gave me a flat edge to work against while sanding the area where the stem meets the shank and keep the shoulders unharmed. I will post a follow-up with photos of the doweling when I have made those.

ImageImageImageImageImageImage

GBD 9438 Virgin Restoration


Blog by Al Jones

If you have followed my previous posts, you’ve noticed that I am a fan of the GBD 9438 shape. There is just something about the chubby Rhodesian shape that appeals to me. All of the 9438’s in my collection are excellent smokers and feel great in the hand. For the past two years, I’ve been on the lookout for one of the highest grades in that shape, the Virgin. I found this somewhat tattered 9438 Virgin with a Perspex stem on Ebay.

The pipe showed some bruising and nicks on the bowl, but the top looked in decent shape as did the Perspex stem. Photographing details of a Perspex stem is never easy, but this seller had plenty of good photographs.

Below are the pictures posted by the seller.  You can see the handling marks on the bowl in the first shot.

GBD_9438_Virgin-Before (10)

GBD_9438_Virgin-Before

GBD_9438_Virgin-Before (1)

GBD_9438_Virgin-Before (2)

GBD_9438_Virgin-Before (5)

GBD_9438_Virgin-Before (6)

The bowl had a light cake, which I reamed close to the briar with my Castleford reamer. I soaked the bowl overnight with Everclear and sea salt. I use a champagne cork to plug the shank end and try to work a little of the salt/Everclear slurry into the shank.

The stem was in pretty good shape, but had a tooth indention on the lower side and some scratches. I tried to lift the tooth mark with some heat, but the Perspex isn’t as resilient as Vucanite. I removed the scratches with some 1500 then 2000 grit wet 3M automotive grade wet sandpaper. Next I completed the stem work with 8,000 and then 12,000 grit micromesh sheets. I buffed it lightly with some automotive plastic polish. The draft hole isn’t heavily stained, which is a fortunate find on a Perspex stem. The tooth mark is on the bottom and the clear Perspex hides it nicely. (and makes it difficult to photograph)

My biggest concern about the briar was what appeared to be handling pinprick marks in several spots, probably from banging around in a drawer/box for a few decades. Using a torch, wet cloth and a pirated kitchen knife, I was able to lift a majority of the marks. The nomenclature was light, so I carefully buffed the bowl with first White Diamond then two coats of carnuba wax. That helped even out the color and hide some of the bruising. It’s not perfect, but has a nice level of patina.

GBD_9438_Virgin_Finished (6)

GBD_9438_Virgin_Finished (1)

GBD_9438_Virgin_Finished (2)

GBD_9438_Virgin_Finished (3)

GBD_9438_Virgin_Finished (4)

GBD_9438_Virgin_Finished (5)

GBD_9438_Virgin_Gallery

With this addition of this Virgin, I now have five different grades of the 9438 shape.

Fantasy

GBD_9438_Fantasy_Gallery 3

Tapestry

GBD_Tapestry_9438_2nd_Gallery

Prehistoric

GBD_9438_Prehistoric_Gallery

New Standard

GBD_9438_New_Standard_Gallery

I include this Seventy-Six Colossus as it is an oversized 9438 (stamped 9676) and clearly the 9438 chubby Rhodesian shape.

GBD_Colossus_76_Gallery

Repairing a Stem on a Dr. Grabow Grand Duke with Black Superglue


I took on this project to demonstrate how I use black superglue to repair deep bit marks/bite throughs on vulcanite stems. I had this old Grabow stummel in my box and I found a stem that looked good on the bowl. The bowl had a small hairline crack in the shank so I pressure fit a band on it for a repair. The bowl needed to be topped so I did that after banding. I restained the top to match the bowl colour. I used a dark brown aniline stain that I mixed with isopropyl alcohol until I got the match I was looking for. I stained and flamed the rim to set the stain. The stem was in pretty rough shape but I decided to use it anyway and take it on as a project. The button was almost gone from the deep bite marks. There were three bite marks on the underside of the stem near the button and on bite mark on the top of the stem. I decided to use the boiling water trick to try to raise the dents as much as possible. These were deep bite marks and the edges were rough so my guess was that they would not come up to the surface with the heat. I then sanded the surface of the stem with medium grit emery paper to remove the surface marks and dents and then smooth out the area of the deep bite marks. I work to have a semi rough surface for the superglue to bond with so I am not sanding it smooth as much as working it over to make it clean. The next three photos show the state of the stem after I had sanded it and readied for patching.

ImageImageImage

Once I had sanded the surface smooth I used my needle files to recut the sharp edge of the button and rework the flow and angles of the button. I also used the needle files to carve the surface of the stem and provide a gentle slope to the new button area. I have found that often when recutting the button and defining its shape it is easy to cut a trough and make a hump in front of the newly shaped button so I always start about half way up the stem and use the file to change the taper to flow to the edge of the button. This served the dual purpose of removing high spots on the bite marks and to help identify the actual holes that would need to be patched. The next two photos show the file work on the stem.

ImageImage

Once I had the slope correct and the button shaped I put the stem in the ebony block I had drilled with a mortise to allow me to sand the rest of the stem without rounding the shoulders of the stem. I wanted the stem shank junction to be smooth and well fit. I also wanted the oxidation removed from the stem before I patched it with the superglue. I did not want the oxidation to remain in the holes that I would patch or on the surface of the stem. I sanded it down and removed the oxidation. I spent extra time around the bite marks. I also picked out any loose debris in the marks with a dental pick and then wiped it down with alcohol to remove the dust and provide a clean surface for my patch work.

ImageImageImage

The next series of three photos show the patch in place. I use black superglue that I pick up from Stewart-Macdonald http://www.stewmac.com/shop/Glues,_adhesives/Stewart-MacDonald_Super_Glues.html I have found that it really works well. I drip it on the cleaned hole and make a bubble of superglue. This particular glue dries slowly so I do one side of the stem at a time. I let it dry for over an hour before turning it over and doing the same thing on the other side of the stem. Once I have made the patch I set the stem aside to dry overnight. I do not want to touch it or sand it until it has had that time to cure and become hard. I have tried sanding sooner but always end up patching the holes a second time because of my impatience.

ImageImageImage

Once the glue has cured and is hard it forms a small bubble of black on the surface of the stem. I sand the bubble flat to the surface and taper of the stem. I use a 320 grit sandpaper to accomplish this sanding. At this point in the process I am not looking for shininess or polish I am only trying to blend the patch into the surface of the stem. The next five photos show the process of sanding down the bubble and the look of the resulting patch on the stem. The tooth marks are gone and in their place is a black patch that with a bit more polishing and sanding with micromesh will blend into the stem well and give a new polished look and comfortable feel to the stem.

Image

The underside of the stem. Notice the patch near the button after sanding with 320 grit sandpaper. The patch on the underside is larger than the one on top but it not as deep.

Image

The bubble of black superglue on the top of the stem. The white dust on the stem is not a problem as the bubble is dry at this point and ready to sand.

Image

The top side of the stem after the initial sanding of the bubble. It is almost smooth and needs to be wet sanded with the micromesh sanding pads.

Image

Top side of the stem after the patch has been wet sanded with 1800 grit micromesh sanding pads.

Image

The top side of the stem after the patch has been wet sanded with 1800 grit micromesh sanding pads. There are still scratches that remain in the stem on both the top and the bottom that more sanding will remove. The patch will also blend in better as the stem itself begins to shine.

The next series of photos show the stem as I sand it with the various grits of micromesh sanding pads. Between the 2400 and the 3200 grit sanding pad I scrubbed the stem with Maguiar’s Scratch X2.0 to polish out some of the remaining scratches.

Image

The top side of the stem after wet sanding with 1800 grit micromesh sanding pads.

Image

The underside of the stem after wet sanding with 1800 grit micromesh pads.

Image

The top side of the stem after wet sanding with 2400 grit micromesh pads. The patch is beginning to be harder to see on the surface of the stem.

Image

The underside of the stem after wet sanding with 2400 grit micromesh pads.

Image

The top side of the stem after I polished it with the Maguiar’s Scratch x2.0. The patch is blending in very well on the top side. If you did not know where it was it would be hard to see.

Image

The underside of the stem after polishing with the Maguiar’s. The patch is also beginning to blend in very well on this side of the stem as well.

Image

The top side of the stem after I had dry sanded it with the 3200 grit micromesh pads.

Image

The underside of the stem after dry sanding with the 3200 grit micromesh pads.

Image

Topside of the stem after sanding with 3600 and 4000 grit micromesh pads. The patch is virtually hidden to the camera at this point as the stem begins to shine.

Image

Underside of the stem after sanding with 3600, 4000 grit micromesh pads.

Image

Top side of the stem after sanding with 6000, 8000 and 12,000 grit micromesh pads.

Image

The underside of the stem after sanding with 6000, 8000 and 12,000 grit micromesh.

The next series of four photos show the finished pipe after buffing with carnauba wax and a soft flannel buff to give it a shine. The pipe is restemmed, repaired and ready for it next smoke.

ImageImageImageImage

 

Cleaning Up an Interesting Dr. Bernard Deluxe System Pipe


When I initially took this one out of the box I figured it would be an easy cleanup. It did not turn out that way. It is stamped Dr. Bernard over de Luxe on the left side of the shank and on the right side it is stamped ALGERIAN BRIAR over France and that is stamped over Made in France. The first two lines were not lined up and they are actually on top of the made in France line. The finish looked pretty clean and the bowl and rim were also clean. The stem was lightly oxidized and had a stamp on it that says Dr. B. It also had a little tooth chatter near the button on the top and the bottom of the stem. The first four photos below show the pipe when I started.

ImageImageImageImage

The worst thing on the exterior of the pipe was a large fill, about the size of the end of my thumb. It stood out in all of it pink putty look each time you held the pipe in your hand. It is clear in the photo below. I thought about rusticating the pipe but decided that with a fill that large I would be better off leaving it alone. I would have to work on it to try to blend it in a bit better with the stain on the bowl.

 

Image

I decided to address the tooth chatter and oxidation on the stem first. I sanded the tooth chatter with 320 grit sandpaper to remove scratches and marks. The first two photos below show the tooth chatter removed and now the stem would need to be sanded and polished. The next series of four photos show the filter apparatus in place and after I took it apart to clean it. I then removed the stem from the shank, cleaned out the shank and examined the filter apparatus on the pipe. I removed the cap from the end of the filter and underneath was a metal tube inside the shank. I cleaned the stem with pipe cleaners and isopropyl alcohol and then cleaned the cap with cotton swabs and isopropyl. Once it was clean I polished it with 0000 steel wool to give it a shine and remove the stains on the metal. I also sanded the stem with a fine grit sanding sponge to begin to remove the scratches and oxidation.

ImageImageImageImageImageImage

I went back to the fill on the bowl. I decided to draw in some graining on the fill that matched the grain surrounding it using a permanent marker. I have done this in the past and it allows you to blend the stain on the bowl and mask the fill so it does not stand out as much.

Image

After drawing on the grain pattern I stained the bowl with an oxblood stain. The first photo below shows the finished look. Once the bowl was dry I buffed it on the buffer and the stain coat wiped off in major chunks. It did not permeate the bowl at all. I also was able to wipe of the grain pattern I had drawn on the pipe. This kind of frustrating occurrence while cleaning up a pipe is just part of the process. I cleaned off the stain with a cotton pad and acetone and then noticed that the pipe had been given a very thin coat of varnish (matte finish) over the bowl. I would need to remove this finish in order to restain the pipe. So back to the table it went.

Image

I wiped down the bowl with acetone until the varnish coat was broken and then sanded the bowl with the fine grit sanding sponge to remove the remnants of the finish and get back to the briar itself. The next three photos show the cleaned bowl. The large fill on the back side of the bowl is also very clearly visible. I then redrew the grain marks on the bowl with the permanent marker to blend in the fill a bit more. In the fourth photo you can see the lines drawn in. They may appear to be too many and too dark at first look but I have learned that once I have stained the bowl with a few coats they will dissipate into the stain and will match the grain pattern in the bowl.

ImageImageImageImage

I worked on the stem and used the micromesh sanding pads from 1500-12,000 grit to polish the stem. I coated it with Obsidian Oil and set it aside. I restained the bowl with aniline based oxblood stain. I applied the stain heavily to the area of the fill. I flamed it and them polished it on my buffer. The next six photos show the restained bowl. The stain took this time. It also covered the fill but the lines were still to visible to my liking. I needed to add some more stain and let it dry this time without wiping it off or buffing it. I needed a bit more opacity in the stain on this portion of the bowl.

ImageImageImageImageImageImage

So I applied some more stain with a cotton swab to just the fill portion of the bowl. I set it aside to dry overnight and in the morning hand buffed that area of the pipe. I hand buffed with a shoe shine brush and a soft cotton cloth. Once I had finish I buffed it lightly with carnauba wax multiple times to give it a protective coating. The final four photos show the finished pipe. The fill is much more blended into the stain coat and the lines are there but more subtle. The fill is not as glaringly staring at you while you hold the bowl. The pipe is ready to smoke and for me to experiment with the interesting filter apparatus.

ImageImageImageImage

Jichimu Wood Pipes – Robert Boughton


中國雞翼木頭

Jichimu Wood Pipes –  Guest Blog by Robert M. Boughton

“I think there should be collaboration, but under my thumb.”

—Elia Kazan, 1909-2003, Movie and Stage Director

Introduction

All jokes aside, however waggish, every successful endeavor in life, from beginning to end, involves collaboration.  I emphasize the word successful since, of course, Man has free will as a prerogative and always, therefore, the choice to go it alone – to be able to say at the final moment, as Frank Sinatra rejoiced in song, “I did it my way.”  As a writer, for example, I may be competent, but even Ernest Hemingway had Maxwell Perkins as his brilliant editor for most of his literary career, and Elia Kazan (quoted above) directed such movie titans as Marlon Brando, Vivien Leigh, Gregory Peck and on multiple occasions Karl Malden, all of whom had something to do with their two-time Academy Award-winning master’s ultimate success.  The word collaborate, from the Latin co for together combined with laborare, meaning, as one might guess, to labor or work, also has a negative connotation.  The four-year French Vichy Regime’s coöperation with the Nazis during World War II, in which certain French military and civilian leaders surrendered to Germany in exchange for a deluded pretense of self-government without such details as a new constitution, comes to mind.  Yet the same negative collaboration of these traitorous Frenchmen led to the positive sort, including the infamous underground Resistance Movement, and in turn became instrumental in the Allied invasion of Normandy and the ultimate liberation of France.

If perhaps on less historic and adventurous levels, most of us, throughout our lives, seek the help and experience of friends and even the kindness of strangers, so the concept of collaboration came easily to me.  I long ago learned to ask questions when I did not know the answers.  Again, I emphasize the phrase for the most part: my dear dad, who is still with us, is a genius and by consequence a fount of enlightenment on at least a passable level in almost every study of human knowledge (except literature, which when brought up created an odd defensiveness in the man).  While he was happy to explain to me in detail diverse topics — including what makes the sky blue, the technical elements of Old Master paintings, the rudiments of handwriting analysis, the basic design and operation of a combustion engine and the concept of imaginary numbers — for definitions or spellings of words or synonyms and antonyms, my father in his own inner crucible reached critical mass when I was about 13 and started referring me without hesitation to his huge, old, worn editions of Webster’s Unabridged Dictionary  and Roget’s Thesaurus until I learned to seek them out myself.   Of course, I did not much care for my dad’s well-meaning if snarky habit of advising me to engage my brain before my mouth, but I am grateful nevertheless for the gift of research he taught me.  Now I prefer my own complete Oxford English Dictionary and the Oxford American Thesaurus or a great online alternative for the latter.

To be honest, though, for most of my life I have been the one doing the majority of seeking of knowledge from other people, whether asking outright or trying to get the desired information in a more oblique manner, or as a writer employing my powers of observation to study the characteristics, voices and other nuances that raconteurs everywhere simmer together in their stories.  And so I had an uncommon, almost uncomfortable, tingle of pride when the refinishings and restorations of the two jichimu churchwarden bowls that are the topic of this blog were complete and I asked Chuck Richards (my fellow local pipe club member and the master restorer responsible for the main work on one of the pair}, with all sincerity, what I could have done better to prepare and wax by hand my project – and his reply was, “Absolutely nothing.”   Then, just this past month, Chuck gave me a real loop at our club meeting when he began to speak about a 19th century Colossus Pipe Factory (CPF) Best Make, real gold-banded, amber-stemmed, turned bowl lion’s head Meerschaum he had acquired in trade and mentioned that he had a challenge.  After he unveiled the damaged but gorgeous golden Meer and passed it around the room for all of us to adore, and suggested that the details of its maker were a mystery to him, Chuck smiled and revealed that the challenge was for me to take the invaluable CPF home and see what I could dig up online about its origins.  To say the least, I was dumbstruck by Chuck’s trust in me.  To be more specific, I was honored beyond words that he wished to collaborate again on a different project than that which I will soon begin to address.  Maybe I’ll get back to the CPF another time.  By the way, I didn’t find much online that Chuck didn’t already know.  The exercise was only a test he knew I would enjoy.

jichimu1

Robert M. Boughton,
Photograph © Robert M. Boughton

jichimu2

Chuck Richards.
Photographs © Robert M. Boughton

Jichimu Wood, and a Note on One Pretender

Jichimu, or 中國雞翼木頭 (the literal translation of chicken wing wood), is a beautiful, unique, porous wood named for its tight, feathery quality resembling the wings of some chickens or pheasants that can change in color depending on the lighting or different angles of view.  Thus it has come to be known in common language as chicken wing or phoenix tail wood.   The estimation of this hardwood as one of China’s three most valued materials for antique furniture and other craft work is unequivocal.

jichimu3There are, in fact, two kinds of jichimu: old and new.  The old variety, being denser and purplish-brown, when cut straight allows for the magnificent patterns described above.  The new growth has purplish-black, straight, unclear grains (some purple, others black).  The wood is coarse, straight and rigid and therefore apt to split.  It is of the old jichimu that our refinishing and restoration projects are concerned.  The use of jichimu in royal furniture appears to date to the Ming Dynasty (1368-16jichimu444) and to have ended in the mid-Qing Dynasty (1644-1911), and although old jichimu still existed, it reportedly was replaced in woodworking in general by the new variety and other woods at the same time.  This explains why my chancing upon not only one but two virtual twin old jichimu churchwardens –they themselves being rare specimens of this type of pipe making – was, to say the least, fortuitous.

jichimu5

Jichimu pipe.
Photograph courtesy of and © Steve Laug.

While the most common use for jichimu isfurniture, in particular antique, just a few other items made with the favored and rare wood include chopsticks, bows for classical stringed instruments such as violins and cellos, iPhone cases – and, of course, smoking pipes.

jichimu6

African Wenge Pipe.Photo © Robert M. Boughton.

Now for a special warning about certain smoking pipes that are being advertised on Websites such as eBay as Chinese Chicken Wing Wood, of the genus Ormosia henryiAt least in most cases, these pipes (which appear authentic in almost every way) are in fact made of Wenge wood, a similar-looking but lesser-quality for pipes African genus (Millettia laurentii).  While still made from a very exotic wood, Wenge pipes lack the richer coloration and attributes more suitable for durable smoking pipes.  I found out the hard way: I bought one on eBay from a dealer in the People’s Republic of China with an excellent reputation, but I cannot bring myself to gripe at the total cost of $14.62 including free shipping. When the pipe arrived early, I noticed the Wenge marking on the right side of the pipe and thought it must be the maker or location.  Imagine my surprise when I Googled the name and came up with the truth.  Still, the Wenge smokes well and is one odder pipe for my collection, as well as a great conversation piece.

How Two Old Wood Jichimu Churchwardens Found Me

A funny thing happened during a trip to my local head shop a few years back, where I was, alas, well known.  No, I was not a patron of the establishment for, shall I say, its illicit wares.   In fact, although I am reluctant to admit the truth in so public and permanent fashion, I must, in order to clarify the reason I believe these two all but twin jichimu bowls found me rather than the other way around, make this digression.  You see, I found myself these years ago in this fine example of everything a well-rounded head shop should be, however rebuked its sort as a whole, after I had for the most part begun buying all of my pipe necessities at my local tobacconist.  But that night, I was in desperate need of pipe cleaners, which I knew the head shop just around the corner from where I lived carried, and my regular source had been closed for almost two hours.  What was I to do?

Of course, without a qualm I rushed to my car, risking a boondoggle because of the nefarious nature of my neighborhood (known in Albuquerque as the War Zone thanks to its high rate of violent crime).  I made my zigzag dash through long blocks of murky streets, slowing for multiple speed bumps and making a Byzantine course around all of the road barriers – these obstacles being in place to aid police in the apprehension of armed robbers and other dangerous felons – and in this fashion accomplished my mission through the free fire zone that would have taken a mere three block walk straight down my street and a brief jog across Route 66 had I been willing to risk a more than possible firefight with unknown strangers and perhaps even having to shoot the drug-addled ne’er-do-wells in this wild southwest Stand Your Ground state.  At any rate, I arrived intact at the head shop and was greeted as a friendly by the night crew despite my several-month absence.  As I told them what I needed, however, out of the corner of my eye I noticed in the glass case that the shop’s former meager stock of tobacco pipes had increased, and for the better.

Suffice it to say I was compelled to have a look, and the result was love at first sight, or at least lust, for the huge, thick, lustrous bowl and that which I could see of the apparent wavy lines of grain alone.  The stem itself appeared to be of shiny black Lucite and crafted with intricacy that included a wider, beveled round base section that then tapered and curved upward into the bit.  But the bowl – well, the bowl on its own merits had an intoxicating, alluring effect on me.  As a whole, the pipe I beheld was one of the most curious looking churchwardens upon which I had ever laid eyes.  The extraordinary pipe, with its ample bowl (1-3/4” x 2” outer and 1-1/4” x 1-3/8” inner), five-pronged head and shiny dark reddish although perhaps overdone coating seemed almost a fantastic contrast to the typical, more Elven-style churches in fashion.  Upon caressing and inspecting the pipe, which I was amazed to find could accommodate my index finger almost to the second joint with wiggle-room, in part by instinct I concluded $30 was a no-brainer.  At the time, the idea that the type of wood from which the pipe was carved would ever prove to be anything but briar never even occurred to me.

I must admit at this point that I was surprised not only when the stem broke but by how little time I had to enjoy my new churchwarden, which turned out to be quite a good smoker, before the sudden and catastrophic damage occurred without even any warning.  One minute I was sitting at my computer and smoking the church; the next, the stem snapped, and by chance I caught the bowl between my legs on its way to the hard tile floor.  Although every instinct in me opposed the idea, I had some Super Glue on hand and considered re-connecting the stem until I discovered not two but three pieces were involved, two large and one very small and jagged – and that they were cheap plastic.

Thinking without much hope that the head shop might have a spare stem on hand, and not knowing at the time that I could order a good one online, I returned whence I purchased the original.  Not to my surprise, the shop did not have a replacement for the stem except, to my astonishment, in the form of another, near twin version of the original product intact.  With some trepidation (after all, $30 is nothing to throw away, and I still was in the dark about the rareness of the wood from which each pipe was carved), I surrendered to the clerk’s laid-back upsell, despite my nagging suspicion that even in a head shop there existed a drawer, cupboard or box somewhere in the back area that contained a plethora of exchanged, discarded or otherwise abandoned samples.  Still, deep within the left side of my brain as I bought the whole pipe again – this one of which had but the slightest darker grains along the front and back of the bowl – was the idea that I might at some point locate suitable stems for both and sell or trade one of the two atypical churchwardens to an appreciative aficionado.  As an afterthought, I even went so far as to scrutinize the new stem for cracks or other imperfections.  In short, because of my original trip to the local head shop for some tobacco pipe cleaners and subsequent additional purchase of one still-unidentified jichimu churchwarden, the stem of which soon broke calling for another visit to the shop hoping only to find a stem, I ended up with two old wood jichimu churches.  Sure, I believe in coincidences, but this was too much.

I hope by now you can foresee the next part.  After a few satisfying smokes of the new pipe – in fact, just enough to break in the bowl – the prior misadventure was revisited.  Through neither any fault of my own nor evident structural flaw, did the stem just break again in mid-smoke, and what was more, showed eerie signs of interference by way of the three pieces I located just as in the previous incidence.  I am sure anyone reading this will either think me outright mad or be able to imagine why my thoughts turned to the notion, however uncanny, that perhaps I was not meant to smoke these pipes for preternatural reason(s) unknown.  At times simple anger is the best natural response, however, and with that in mind I tossed both of the then useless bowls and the bottom half of one of the 9mm stems into the glass jar of the only stand I had at the time, a little nine-piper I found at a garage sale about 23 years ago.  There the two ever-alluring disembodied heads, as it were, would stare out at me from time to time with their come-hither looks.

Early Collaborative Restorations

jichimu7

La Grande Bruyère Before. Photo © Robert M. Boughton.

jichimu8

La Grande Bruyère After. Photo © Robert M. Boughton.

Around that time, although I’m not at all sure of the date, I began dabbling in refinishing pipes.  I started with a La Grande Bruyère mini made in Czechoslovakia that I bought – again at a garage sale – sometime in the late 1980s and never smoked until one night when I took it out and examined it with a magnifying glass to make out the brand and decided to clean and try it.  To my surprise, it was a wonderful smoke.  So I carefully stripped all of the tacky red varnish and uncovered a beautiful dark grain.  I continued sanding until the tiny pipe was baby smooth, then took it to Chuck and asked how much wax would cost.  He just said “Give it here,” which I did and proceeded to the pipe shop’s sitting area.  Five minutes later he motioned me over.  I was shocked but very pleased to see that Chuck had waxed it by hand, and the transformation was spectacular.

I had several old Italian no-names from my early days of pipe smoking (I started in 1989) that had serious blackening along the rims of the bowls, some moderate to nasty dings and most of all coatings which offended me so much that my perhaps most basic nature made me wonder what lay beneath.   You see, I’m curious that way.  I winged it again, but in the mean time I bought a small jar of Halcyon II Wax to finish them.  Although I later learned that type of wax is best for rusticated pipes, it ended up working just fine on my three natural finish experimentations.  I ended up giving all three no-names to cigar-smoking friends who were interested in pipes, and by doing so won them over, at least in part.  They really only needed a nudge.  I kept the La Bruyère for myself.

The Jichimu Restores

At last, I arrive at the tale of the restorations of the jichimu churchwarden bowls, one wholly by Chuck after my refinishing of it and one by me except for a final quick machine buffing as I do not yet own the proper equipment.  Because of the broken stems, these two restorations were the first I had encountered on my own that were borne of true necessity, other than what I have heard of the backgrounds and solved problems with the many beautiful restores I have had the pleasure and good fortune of buying from Chuck, although, as the next photo shows, the coatings were real horrors.  I suspect some sort of polyurethane glaze was used in the originals, thereby inhibiting these beautiful pipes’ ability to breathe, a crime I deem unforgiveable due both to the rareness of the old jichimu wood I liberated with my loving if strenuous sanding and that wood’s natural  porousness.

jichimu9

Jichimu pre-restore. Photo © Robert M. Boughton.

This was the bowl I handed over the counter to Chuck at our favorite tobacconist, hoping (and therefore having even a little doubt, which of course proved silly) he could identify its dark reddish, feathery wood.  The master restorer took the large bowl from me and, with the briefest squint behind his eyeglasses, through which I noticed a sparkle of slight amusement mixed with a subtle but unmistakable distaste, said:

“It’s Chinese Chicken Wing Wood.”

I remember the slight sting of what I perceived to be a note of contempt in his pronouncement, however well contained and no doubt unintended, as I paused before asking, “Is that good or bad?”

“It’s neither good nor bad,” Chuck said in his baritone voice and shrugged in this enigmatic way he has.  “It just is.”

Now, I swear to the truth of this next part upon all that is holy to me, which by the way is considerable: I will never forget flashing back to the iconic ‘70s TV series “Kung Fu,” with David Carradine as Kwai Chang Caine and Keye Luke as Master Po, and Chuck was Master Po snatching the pebble from my outstretched palm – again!  Being unable to maintain the absurd private response to an innocent comment in no way intended to insult me, I recovered myself and grinned.  I later learned (by doing the unimaginable – asking Chuck)that his primary concerns about smoking a Chinese Chicken Wood Wing pipe were the possibilities of toxicity and what he considered to be likely high maintenance to keep the pipes undamaged because of their soft, porous nature.  I was unable to find any negative toxicity information for the jichimu wood genus (other than the serious dangers involving any kind of wood dust inhalation), and as for maintenance, I treat the restored jichimu I kept for myself with the same respect I afford any of my other fine pipes, such as my Meerschaums and Peterson’s: in this case, by storing it in a pipe box.

At any rate, Chuck examined the bowl I wanted to keep for my own use and, of course, with his quick, keen eye noted the crack in the top of the shank’s stem opening.  Knowing far less then than I do now of pipe restoration (which remains little), I suggested covering it with a metal band of some sort.  I recall being so proud of that idea!  Chuck, being diplomatic, said that indeed would be part of the solution, but the real problem was finding the right type and color of wood from which to shave enough particles to mix in some sort of Super Glue concoction.  Again I made a suggestion, this time redwood, a small piece of which I happened to have on hand at my home.   Chuck thought about the idea for a second before telling me to bring the wood to the shop for him to check out, but there was no hurry because he would have to do the restoration after the holiday store sale madness and pressing personal projects were behind him.

Meanwhile, I prepped the bowl with considerable sanding and buffing by hand, work I later realized at best made Chuck’s task a tad easier in that he would only have to spend a minute or so doing the job properly on his electric wheel.  The hand sanding and buffing I chalked up to valuable experience (as well as being relaxing and pleasant activities), and should be tried first by all refinishing or restoration beginners, just as anyone new to but serious about photography should start with an older standard SLR film camera to learn the true elements of the art form, including developing the film and printing photos in a dark room, before moving to digital and mastering the dubious practice of Photoshopping on a PC.

jichimu10

Ashley at meeting. Photo© Robert M. Boughton.

Seldom since I was a child had a holiday season seemed to take as long to pass as this last one.  In fact, I had a certain pleasant and childish giddiness and anticipation about Chuck’s restoration of my cherished Chinese churchwarden.  I kept myself distracted with my own restoration of the second jichimu bowl, of which I had already determined to make a gift to a young lady who attends our weekly pipe club meetings as often as work allows (she has, I believe, three jobs).  Ashley has two distinctions in our club, one being that she is the only female member and the other that she smokes churchwardens exclusively.  Who better to give a pipe which, although I knew it would be a lovely specimen by the time I was finished with it, nevertheless amounted to a twin of one I owned? Since Ashley is married to another pipe smoker and club member, Stephen, the gift was platonic in its intent, but still I was careful to broach the subject with him one night when I found him by himself by asking if he thought his wife would appreciate not only the idea of the gift but, of more importance to me, the unusual wood.  In fact, I put it bluntly, would the jichimu be something Ashley enjoyed smoking?  I admit I was relieved when Stephen assured me she would love it, and I asked him not to tell her anything about my plan.  Stephen was more than willing to go along.  I even completed a “first draft” of the restore during this time.

jichimu11

Photo © Robert M. Boughton.

Meanwhile, back to Chuck’s restoration work, after the holiday crush at the shop:  he’d had time to mull over the ideas that took time to come together in his head for this project that, for personal reasons we have never discussed but have become apparent to me in the intervening months, somehow meant more to him than the average restoration.  Somehow none of the rarest, most damaged pipes presenting Chuck with the kinds of severe tests of his masterful skills that he had needed to employ in the past and will continue to utilize in the future seemed more important to him than the simple job I had asked him to perform with my well-sanded and unblemished (other than the small crack in the shank) jichimu bowl I had entrusted to his care.  After all, I had only expected him to fix the crack, wax and buff the bowl on his electric wheel, add a nice-looking metal band of some sort and top it all off with a good stem, preferably of a reddish colorized Lucite variety if he could find one.  And of course I expected to pay for it, although he made it clear in the beginning he would cut me a deal.

The key difference between what I wanted from Chuck and how he approaches any job, I soon came to understand, was in Chuck’s great expectations.  While I expected Chuck to have a fast and easy job of making my bowl look as beautiful as I thought it could be and at the same time able to smoke with the addition of a stem, his ideals are far higher than that.  When at last he began to fill me in on his plans for the pipe – such as the fact that he had found a better match of wood for shavings to fill the crack in the shank than the redwood I had left for him a couple of months earlier, and that they were from an empty cigar box he found in the back of the shop – I discerned in his eyes an excitement I had never seen there before.  That, believe it or not, was my first clue as to how seriously Chuck had taken this “job.”   He explained in detail the process by which he would fill the crack and then attach and seal the band and would add only that he had found “the perfect” stem of which he was certain I would approve.  Of course, since the bowl was a churchwarden and that was the type of stem I had requested, I assumed that was what it would be.  But Chuck, being in charge, had far grander designs in mind.  I have to wonder who was the true child at Christmastime.

So, to cut to the chase as it were, I was sitting at home late one afternoon checking my emails when I found one from Chuck that read, as I recall, “Well, are you ready to come get your pipe or not?”  I must have re-read that brief message several times, shaking with excitement, before picking up my phone to call the shop and make sure he was there.  He was, and his laugh could not disguise his own excitement.  So, telling him I would be right there, I fumbled a few jars of tobacco together and was out the door in a flash.

When I arrived maybe 15 minutes later, Chuck was literally glowing, his face beaming with anticipation and a certainty that I would be satisfied.  Still, I have a feeling that deep inside him was a fear of possible disappointment on my part that had to be utterly alien to him.  Here is what he unveiled to me:

jichimu12

Chuck Richards Jichimu Restore. Photo © Robert M. Boughton.

Need I say I was, for lack of any more suitable a word, stunned by the work of art Chuck had created from my once shellacked and smothered but promising jichimu bowl?  As I recall, in fact, I went a little fuzzy in the head and had to concentrate on not swooning, a very rare reaction for me.  At first I was even speechless, for whatever I had expected from Chuck based on the simplistic guidelines I had suggested, he had, it was obvious, ignored in favor of his own better instincts.  As a result, instead of giving me a new and improved version of the original churchwarden, Chuck had embraced the ultimate spirit of the term restoration, bestowing upon the lone bowl a new life that combined both elegance and even a better sense of Chinese style than any churchwarden ever could have accomplished.

“Well, do you like it?” Chuck said after I stood there gaping a tad too long, and I snapped out of my reverie to look at him, my face flushed with gratitude.

“Are you kidding?” I replied.  “I love it!  It’s better than anything I imagined!”

So of course the time had come for the vulgar but necessary formalities of payment arrangements, but Chuck was already prepared with an itemized bill.  Scribbled on a small paper napkin which he slid forward across the counter were three lines of chicken scratch I had to squint at and read everything for context to realize formed the names of his three favorite tinned tobaccos.  At that point I was sure he was having fun with me, and said so, but he was serious.  In exchange for the hours of loving labor Chuck had invested in this project, not to mentions parts, all it was going to cost me was maybe $55.

And so I returned to my project and set about re-doing the preparatory process of stripping down the bowl I had already sanded, buffed and even hand-waxed.  Somehow, taking a much closer gander at the bowl after deciding I wanted to make a special gift of it to someone who possesses an acute appreciation for fine churchwardens, my earlier perception that the only addition the bowl still needed was a decent stem went out the window.  All I can think now is that I must have been blinded in my rush to the finish line.This, I suspect, is a common urge among restorers.There were still dark, even scratchy, areas on the front and back of the bowl where the grain, I was certain, could show with still more brilliance.  Although I had been told by someone in my pipe community that the direction of sanding did not matter, I recalled something I had seen on TV’s original NCIS.  The episode had a scene where some suspect was working on his yacht, sanding the beautiful wooden deck, and Gibbs (who had his own never-ending boat project) acknowledged that the man was doing it the right way – “always with the grain.”  Plus I remembered the same advice from my father, who is also an expert at carpentry.

Then, suddenly, after stripping the new-old coating from the bowl with coarse paper, I switched to a finer grade and began on the front of the bowl with sure, steady strokes following the grain where it turned upward a little.  After a short time, I cleared off all the fine dust, and gazing at the beautiful, much more even and feathery lines I had set free, felt that warm, glowing reward only someone who works with his hands on anything with potential to be better and succeeds at his task will ever understand.  As if in a trance, I kept at it until my arm ached, and when I was finished with the front let my enthusiasm carry me onward to the backside, which responded with equal elegance.  Admiring the reborn pipe bowl, I was satisfied at last that it was in all truth ready for buffing.  This practice has its detractors, but I like to use fine steel wool for the final gentle buff, being extra careful, of course, to remove the entire resulting metallic residue with a dry cloth.  With that done, I was ready to apply my wax sparingly with a finger until the entire outer bowl was covered.  Giving it time to dry, I wiped it smooth and clean with a soft cotton T-shirt that was too old and small for me to wear and ended up repeating the wax step once more.

After cleaning and sterilizing the bowl and shank with alcohol, I knew that was the best I could do– again, I pined for an electric buffing wheel – and had only the long black Lucite stem Chuck had given me on which to sand down the tenon to fit the shank of the bowl.  That was all I needed to do, he said, suggesting the job would be easy.  Indeed, with an electric wheel it would be, but with the tools I had at my disposal – such implements of potential destruction as sandpaper and a wood file – I harbored, to use a nicety, misgivings.  After all, I know my limitations and am almost always first to admit them, which I will now prove.   Trying to sand down the tenon by hand got me nowhere, so I switched to the wood file.  Now, there are mistakes, and then there are total write-offs.  Within just a few seconds’ time I found myself staring in horror at the resulting apparent near mayhem I had perpetrated upon the unfortunate, innocent opening end of the tenon.  Even after sanding the mangled, tapering pooch-job I had made of it, I still was left with only a smooth (if such it could ever be called again) version of the atrocity that reminded me of every time I ever tried to use one of those electric head grooming sheers on myself – you know, the kind with which barbers go to school to learn to operate on complete strangers with enough skill that they won’t be sued for the results but that are offered in stores in cheaper versions guaranteed to be so easy to do it yourself, only you can’t sue yourself for the one gaping bald gash that always results sooner or later and leaves no option but to shave off all the rest to make the disaster even.

Luckily, I had two things going for me: 1) I knew when to quit for the night and pray that Chuck would be at the store the next day for more of that collaboration, and 2) Chuck had given me a stem with a tenon so long I could afford one screw-up, even after I had already clipped off about a half-inch of the excess.  I knew Chuck was going to tell me I had to get rid of the evidence of my muddled first attempt at stem fitting the same way and at least had the courage to show him the scope of my “bad” in the fullness of its butchery, hoping only that he wouldn’t make too much fun of me as he said the words himself.  Part of me now likes to think Chuck was wise enough to anticipate just such a mishap,, and that’s why he gave me a stem that once had such an enormous tenon in the first place.  The next day, with the shameful proof of my ineptitude tucked deep within my coat pocket, I ventured into the tobacco shop and spotted Chuck at the far end of the long counter that ran to the back on the right side.  He glanced up from what he was doing at the sound of the door chime, saw who it was and continued working.  He knew my routine, which I followed then with nervous mind a jangle, walking to the sitting area and setting down my heavy tote bag filled with a variety of excellent pipes and tobaccos from which I could sit a while and choose at leisure.  Taking my time to claim my favorite comfortable cushioned chair – the only one with a full view of the store because it panders to my life-long discomfort of having my back to a room – I was all-too-soon settled in and made my way with the vile stem in hand to Chuck.

Of course when I displayed to him the mess I had made, Chuck was as gracious as ever, which is not to say lacking in some bemused gruffness, but I was put at ease with a wonderful combination of relief and kinship when he did his best, I have no doubt, not to break into outward laughter.  He could read my face despite its poker table nature and allowed only a genuine grin of appropriate amusement to show on his.  The grin said at once, without a word yet spoken, “Been there…done that,” even if not with the same aptitude.

I sit here at my laptop as I near the conclusion of the tumultuous account of the tale of two jichimus, smoking a soothing bowl of Rattray’s Brown Clunee in my own Chinese Phoenix Wood.  (I like the mythological sound of that better.)  The second bowl needing only the stem and a final quick wheel buff by Chuck, I managed a passable job on the church stem – at least enough to make it fit the shank snugly – and polished the Lucite to a fine luster.

jichimu13

Robert Boughton jichimu restore. Photo © Robert M. Boughton.

When the time came to present the pipe to Ashley at our weekly meeting, which she attended knowing something was up but having no idea what it was, I recommended upon giving it to her  that she might consider finding a replacement stem, or at least arranging to have it curved.  But she filled the bowl in delight and lit it up for the first time, and the look of satisfaction and pleasure on her face were all I needed to put the project to bed.  She insists to this day that the jichimu is one of the coolest, smoothest smoking pipes she owns.

Conclusion

The end of any serious undertaking tends to be followed by a period of time that can be described as both exhilarating to a degree but more of a let-down over-all, and the only cure for this edgy malaise is a new game plan to replace the last.  The conclusion of the jichimu restoration project, not the least of which is marked for me by this writing,leaves not an actual dearth in my life except for the heartfelt kind, for I found in my meager contributions to it a new calling of which I had only imagined I might one day have a genuine calling and now know the suspicion, or dream, is more than that.  As I suggested earlier in this account, I have long known the pleasure of using my hands in woodwork, in particular the simple tactile nature of wood itself, and of taking apart such things as old furniture and stripping off the old paint and varnish to be improved – after attentive, deliberate, meticulous preparation – with fresh new replacements.  Now, on the verge of acquiring an electric buffing wheel because the time has clearly come to stop passing off that final touch, I know I have a future in pipe restoration if not their actual making.

In my near future, therefore, I see several tasks I have been procrastinating, most of them remaining literary in nature but the third having a distinctly different approach to woodworking than pipe restoration: a very old padded rocking chair that has remained unused outside, over time collecting dirt and losing more and more of its stuffing, its fine brass screws, nuts, washers and bolts tarnishing, its lack of attention and use leaving it, as it were, almost lonely – if indeed a natural born writer with a flair for woodwork could personify an old rocker.

But I expect I will have to start my own blog to tell the tale of that restoration.

A Little Czech System Pipe Reborn


I had this little Czechoslovakian rusticated bowl in my box. I decided it was the day to work on it so I took it from the box and gave it the once over to see what needed to be done. The finish was a bit spotty, and the shiny varnish on it was peeling so I dropped it in an alcohol bath to try to break down the finish. The next three photos show the bowl after I had taken it out of the bath. While it was still wet I used a wire brush and some Everclear to scrub the surface of the bowl to remove the flaking finish and the varnish coat. I also topped the bowl to remove the damage that had been done to it from tapping it out. The fourth picture below shows the topped bowl

ImageImageImageImage

I went through my can of stems to find one that would fit. I had a nice p-lip style stem stamped WDC Wellington that came from a pipe of similar size and shape. I was able to sand it a little to make a good fit tight fit to the shank. I cleaned up the stem with micromesh sanding pads 1500-12,000 and then gave the stem a polish with Maguiar’s. I sanded it a final time with the 12,000 grit micromesh before wiping it down with Obsidian Oil. The two photos below show the finished stem.

ImageImage

I restained the bowl with dark brown aniline stain, flamed it, restained and flamed it a second time. The restained pipe is shown in the next two photos. Once it was dry I took it to the buffer and buffed the stem and the bowl with White Diamond.

ImageImage

 

I brought the pipe back to the work table and gave it multiple coats of the Halcyon II wax as I find it does a great job giving rusticated pipes a nice sheen. I also coated the stem with carnauba wax and hand buffed the entire pipe with a shoe shine brush. The hand buffing brought out a nice shine on the pipe.

ImageImageImageImage

 

Experimenting with Alternative Oxidation Removal Techniques


Blog by Greg Wolford

I’ve recently been involved in a conversation about removing oxidation on stems with steel wool. I have to be honest, at the first mention of steel wool being used on a stem made my jaw drop (literally, almost dropped my pipe). But these guys are long time pipe smokers and restorers so I didn’t just brush off the information.

They said that using 0000 steel wool, dampened with water, removes oxidation much more efficiently than miracle erasers, Bar Keepers Friend or any micro mesh/sandpaper treatments. The increased efficiency also reduces the time invested I am told, which makes sense and is appealing.

So I decided to try an experiment on two old stems. These stems weren’t in terrible condition but had some oxidation to them and they were nothing too valuable if I made a real mess of them: they are expendable so they became my test subjects.

20130312-095418.jpg

I soaked them in a room temperature OxiClean bath for about four hours or so; I had to leave the house for a while so I made sure the water wasn’t too warm and left them to soak while I was gone. When I got home I washed them with dish detergent and a scrubby sponge until they no longer felt slick: about 2-3 minutes. They were the. Left to air dry on a drain board overnight.

20130312-095310.jpg

Yesterday morning I went out and bought some supplies: a package of 0000 steel wool and some 400 grit wet/dry sanding sticks; the sticks, or pads, remind me of short wide emery boards.

I took a piece of the steel wool and dampened it and began to rub the stems. Every few minutes I would wipe off the stem on an old towel, rinse out the wool, and go back to rubbing. It took very little time to remove the signs of oxidation and the stems were much less matte finished than they usually are after initial sanding. So I turned my attention to the stem with the stinger to work on the chatter.

I used the new 400 grit pads to wet sand on the chatter, going back and forth, wiping and rinsing as I had with the wool. These pads seem like they will be very useful in getting into that hard (for me at least) to get bit area and is why I bought them to begin with. They did, indeed, reach into that area much more easily and they took out the chatter fairly fast. That area was now more matte than the rest of them stem so I went back to the damp steel wool. In a few minutes the shine came back up even across the stem, which actually surprised me.

The whole process, not including the soak and dry time, took less than 15 minutes; I was again impressed.

20130312-095310.jpg

Will steel wool scrubs replace all the sanding and micro mesh polishing? I don’t think so. Will it reduce the amount of time and effort spend making an old stem look new again? I believe it can. I expect to explore with more stems just how effective this process can be and how much sanding and polishing can be avoided using the steel wool. One fellow said he can go straight to the buffer after the wool scrub. On some stems that may be a possibility but I think on most it won’t. Any chatter or deep marks I think are still going to require sanding. And if you have a rough stem after the oxidation is gone I think it’s still going to need sanding, too. But this is a (new to me) technique that I think needs more investigation and experimentation, one that potentially reduce the amount of time and labor spent on many stems, letting is be more productive overall.

20130312-095226.jpg

Stem after using 400 grit pad and 0000 steel wool to remove chatter and bring back up some shine.

(Photo of the stem at the point I stopped along with the 400 grit pad I used and the packaging it cam in. By the way,  my local Hobby Lobby has begun to carry a rather large line of Micro Mesh and Alpha Abrasives products. The prices are competitive and the selection good so if you have a local Hobby Lobby it would be worth your while to see if they are carrying these items in your area, too.)

New Selection of Micro Abrasives at Hobby Lobby

Reviving a Genod Shaped like a 9242 GBD


Blog by Steve Laug

When I saw this one on EBay I immediately put in a bid that would make it mine. When it arrived this is what it looked like. The bowl was relatively clean and easy to work on. The rim had a pretty serious burn on the inside and the outside edge of the bowl on the right side. It is visible in the second photo below. The bowl was also slightly out of round due to reaming with a sharp blade. The stem was oxidized and was an uneven brown tone. There were two small tooth marks on the stem one on top near the button with a match on the underside near the button. The first picture is a bit blurry but I include it as it gives an idea of the shape of the pipe and why I compared it to a GBD 9242. This one is stamped Genod on the left side of the shank and on the right side Iwan Ries & Co (in script) over the shape 271. 
Image

Image

I cleaned the bowl and reamed it carefully to remove the carbon build up and uneven cake. I then used sand paper to smooth the inner edges of the bowl and bring it back as closely as possible to round. I topped the bowl minimally to remove the burn damage on the flat surface and minimize it on the outer edge of the bowl. For the most part it came out but left a little darkening on the surface of the rim. The right edge also has some remaining darkening and a small divot out of the edge.  I cleaned the shank with isopropyl alcohol and many pipe cleaners, cotton swabs and a shank brush. I then place the bowl in an alcohol bath to soak while I worked on the stem.

The stem is very hard vulcanite. The tooth dents are more cuts than dents and one day I may fill them with super glue but decided to leave them at this point. I sanded the stem with 400 and 600 grit wet dry sandpaper and water to remove the oxidation. It was not terribly deep so it came off very easily. I then used micromesh sanding pads from 1500-6000 grit to polish the stem. When it was finished I rubbed it down with some Obsidian Oil and set it aside to dry.

I took the bowl out of the alcohol bath and dried it off. I used some medium brown aniline stain mixed 50/50 with isopropyl alcohol to lighten and thin it. I rubbed it on with the dauber and then flamed it and buffed it. I put the stem on it before buffing and gave the entirety a buff with Tripoli and White Diamond. Once it was finished it was given multiple coats of carnauba wax.
Image

Image

Image

Image

This little Dr. Plumb Bulldog is a beauty


Blog by Steve Laug

This little pipe came to me via a friend in Germany. I finished cleaning up what has turned out to be a very nice squat straight bulldog that is stamped Dr. Plumb Extra on one side and 13 D.R.G.M. on the other. I have been familiar with Dr. Plumb pipes for quite a while and love the fact that they were a GBD seconds line. In fact they often share the same numbering system for shapes. This little guy had some serious issues when I took it under my wing. It needed a bit of work. The bowl was scorched along the front outer edge of the rim as it looked to have been lit with a torch lighter. The finish was shot and not only faded and washed out but also pitted and darkened along the bowl sides. The stem was oxidized and a bit chewed on the end. The stinger apparatus was dark and filled with tars and hardened tobacco oils.

My friend had started removing the burn mark and the bowl angles were slightly out or line. I finished removing the scorched briar and reworked the angles on all the outer edges of the bowl to keep the perspective and rim correct. I gave a ream and clean to remove any of the remaining cake and the sanding dust that had become embedded in the cracks in the cake. I put the bowl in the alcohol bath and then worked on the stem.

The pipe had the strangest stinger contraption I have ever seen that extends into the bottom of the bowl. It almost looks like a motorcycle exhaust pipe. I have inserted a few pictures of the stinger and fit in the bowl. I removed the stinger and placed in a small bowl of alcohol to soak. The stem was badly oxidized – not the brown oxidation that sat on the surface but a deep oxidation that left the stem a deep brown under the surface. I had been soaking the stem in Oxyclean while I worked on the burn on the rim of the bowl so that when I removed it from the water the oxidation had been brought to the surface. I used my buffer to remove the surface oxidation that had softened. I use Tripoli at this stage and work the stem carefully on the buffer to avoid rounding the shoulders on the stem. Then I sanded it with 240 grit sandpaper until it was matte black and clean. I then sanded it with 400 and 600 grit wet dry sandpaper and water to remove the scratches. I finished the stem by sanding with the micromesh pads 1500-6000 grit until the stem had a sheen to it. ImageImage

I then took the bowl out of the alcohol bath and dried it off. I sanded it with the 1800-2400 grit micromesh pads until the surface was free of scratches and grooves and was smooth. Then I refinished it with an oxblood aniline stain to bring out the red highlights in the briar. I put the stem back on the pipe and took it to the buffer to buff with White Diamond. Once finished I gave the whole pipe several coats of carnauba wax. ImageImageImage