Tag Archives: Bowl – refinishing

Restoring a GFB Bent Billiard – Another Reclamation Project


Blog by Steve Laug

This project was another pipe bowl that was in the lot from EBay. It is a billiard stamped French Briar in script on the left side of the shank and it too was in very rough shape at first glance. It is an old timer. The band on this one was also as badly oxidized as the CPF billiard I wrote of before. It was to the point of being crusty with oxidation and a greenish hue. They were also rough to the touch which led me to believe that they were pitted underneath all of the oxidation. It came stemless but I found a stem of the proper age in my can of stems. The finish was rough, a reddish hue in terms of stain, but there were no deep dings or dents. There was one spot on the right side of the shank near the shank cap where there was a sandpit that had darkened from some bleed off the oxidized shank cap. This one did not have any darkening around the bowl or shank other than the one spot near the sandpit. The shank cap on this one was also loose and when I touched it, it came off (I am glad they stayed on the pipe long enough to arrive here. One of the lot is missing the end cap so that will prove a later challenge. Again after the initial examination I came to see that underneath the grime there was a pretty nice piece of briar. The first series of two photos shows the state of the pipe when I took it to my work bench to begin working on it early this morning.

ImageImage

I cleaned the shank cap the same time I worked on the CPF billiard. I applied the Hagerty Tarnish Remover and scrubbed the cap with a cotton pad. I was able to remove some of the heavy oxidation and darkening but not a significant amount. The next two photos show the process of cleaning the shank cap with the Hagertys.

ImageImage

I dropped the bowl in the alcohol bath with the CPF billiard and let it soak while I work on the CPF pipe. Once it had been sitting in the bath for about an hour I removed it and dried it off.

Image

The next series of four pictures show the pipe after it had been sitting overnight and dried from the alcohol bath. Most of the grime is gone from the outside of the bowl of the pipe and the oxidation on the stem was not fairly smooth – just black and needed to be cleaned. The shank cap also had quite a few dents that would make it a challenge to remove the oxidation.

ImageImageImageImage

At this point in the process I decided to bend the stem. It was pretty clean and did not have any oxidation on it. It merely needed to be polished and shined. So I set up my heat gun and the old rolling pin to bend the stem over and went to work on it. The next three photos show the bending process and the finished bend in the stem.

ImageImageImage

At this point in the process I took the pipe back to the work table and took two more pictures before taking the end cap off the shank and working on the pipe bowl and end cap.

ImageImage

I scrubbed down the shank cap with the Hagertys Tarnish Remover while I had it off of the shank. I also sanded it with my fine grit sanding sponge to remove the heavy buildup of oxidation. It took a lot of elbow grease to clean it off and to avoid damage to the stamping that became apparent in the cleaning of the cap. Once I had it relatively clean I sanded the bowl with the sanding sponge, wiped it down with an acetone wet cotton pad and prepared to reglue the shank cap. I used white glue to reglue the cap. I applied the glue to the shank of the pipe quite heavily as I wanted to close the gap between the cap and the shank. I pushed the cap into place and wipe away the excess glue. The next three photos show that process.

ImageImageImage

While the glue was drying I picked out the grit from the sandpit on the right side of the shank and repaired it with briar dust and superglue. The photo below shows the filled and repaired sandpit just next to the shank cap. The second photo below shows the newly place end cap and the work that still remained on the nickel/silver (?) shank cap.

ImageImage

I worked on the shank cap once it was dry with micromesh sanding pads. I used 1500 – 2400 to wet sand the cap. It took much elbow grease to get it to the point is at in the four photos shown below.

ImageImageImageImage

The GFB stamp on the cap shows up clearly in the photo above and the ones below. There were many small dents in the cap that I was not able to remove. However, I continued to polish the cap with some Neverdull Wool – a cotton product that is impregnated with a tarnish remover. It is soft enough to get into the dents on the cap. I then went on to sand the bowl with the fine grit sanding sponge to clean up the finish. The next six photos show the sanding progress. Once it was finished I wiped the bowl down with some Everclear on a cotton pad to remove the sanding dust and prepare the surface of the wood for restaining.

ImageImageImageImageImageImage

I decided to restain the pipe bowl with an oxblood stain to maximize the stain that remained in the briar. I believe the original stain was oxblood coloured so the look would approximate the original finish of the pipe. I applied the stain, flamed it, reapplied it and flamed it a second time. The first two photos below show the pipe after the application of the stain. The next four photos show the pipe after it has been hand buffed with a soft cotton cloth to remove excess stain on the briar. The filled area near the shank cap on the right side is visible and the darkening of the area is also clear.

ImageImageImageImageImageImage

At this point in the process I set the bowl aside and worked on polishing the stem. I quickly gave it a once over with the fine grit sanding sponge and then worked my way through the micromesh sanding pads from 1500 – 12,000 grit. The next series of eight photos shows the shine that comes to the surface of the vulcanite with each successive grit of micromesh.

ImageImageImageImageImageImageImageImage

I wiped the stem down with Obsidian Oil and then hand waxed it with some carnauba paste wax that I have in the shop. It is the wax available from Walker Briar Works and I will often hand apply it to the stems at this point in the process and hand buff a shine. I then reassembled the pipe, polished the bowl with a little of the carnauba as well. I hand buffed the pipe with a soft cotton cloth I use for that purpose. The next four photos show the pipe after this process. I purposely did this on this pipe to see if the wax would cause the area on the right side of the shank that is darker to blend in a bit and be less visible. It seemed to work very well.

ImageImageImageImage

Once I was finished with the hand buff and had checked out the dark spot I took the pipe to my buffer. I lightly buffed the pipe and stem with White Diamond and then gave it multiple coats of carnauba wax and a final buff with a soft, clean flannel buffing pad. The next four photos show the finished pipe. It has been brought back to life and should well serve a new generation of pipe smokers. I do believe it will live longer than I do!

ImageImageImageImage

As I finished this piece on the GFB pipe I thought I would take some photos of the CPF and the GFB old timers posed together. The next two photos show the pair in their newly found glory. I can’t help but think that this is how they looked when they were purchased by the original owner. I believe that both came from the same pipe smoker so now they are returned to the look that must have caught his eye when he purchased them. The pair look enough alike I wanted you to see them in this pose! A noble pair of old pipes, don’t you agree?

ImageImage

Restored CPF Bent Billiard – A Reclamation Project


This is the second CPF pipe bowl that was in the lot from EBay. It is a billiard and it was in very rough shape at first glance. It is an old timer. The rim cover and the band were badly oxidized to the point of being crusty with oxidation and a greenish hue. They were also rough to the touch which led me to believe that they were pitted underneath all of the oxidation. It came stemless but I found a stem of the proper age in my can of stems. The finish was rough but there were no deep dings or dents. There was a deep, almost black darkening around the bowl just under the rim cap. The darkening was such that made me think that the oxidation had oozed into the briar and would be interesting to remove from the finish. The same was true of the area around the shank cap. The rim cap originally had a hinged lid on it but that was gone. The shank cap was also loose and when I touched it, it came off. The briar underneath was thick with a reddish coloured glue but was also free of cracks or fissures. It was intact. After the initial examination I came to see that underneath the grime there was a pretty nice piece of briar. The first series of three photos shows the state of the pipe when I took it to my work bench to begin working late yesterday afternoon.

ImageImageImage

I decided to work on the oxidation on the shank cap and the rim cap. I wanted to see if either one was redeemable. I used a jeweler’s tarnish remover called Hagerty to work on the finish of both. I applied it with a cotton swab and scrubbed it with that until it was dry. Then I wiped it off with a cotton pad. In doing this I saw that the rim cap and the shank cap were both brass. The rim cap had two tears or cracks in it around the hinge that showed up once it was clean. The next two photos show the tarnish remover on the rim and shank caps.

ImageImage

After the initial cleaning of the two I decided to remove the cracked rim cap. This was not as easy as it appears in the photos as it was nailed to the rim and also was pretty tightly bonded with the tars and oils of the tobacco. I used a pair of needle nose pliers and a flat blade screw driver to lift the edge of the cap. I began at the hinge and lifted it from there. It came off with a bit of work and broke at the two nails that held it to the rim mid bowl on each side. The back half of the cap came off in one piece. I was able to lift the front edge carefully using the flat blade of the screw driver to pry the edge and work my way to the front. The nail on the right side came out with the cap while the one on the left side was stuck. I used the flat blade of the screwdriver to lift it from the surface of the rim without scarring the rim and pulled it out with the pliers. Underneath the rim surface was actually smooth and had a slight caking of oils that would come off easily. The two nail holes would need to be filled. The one on the right side of the bowl had been put in at an angle and would take a little more work to repair. The first picture below shows the torn rim cap on the work table next to the pipe bowl. The holes and the state of the rim are also clearly visible. The second picture shows the darkening that seeped down the edges of the bowl from underneath the rim cap.

ImageImage

I used briar dust and superglue to fill the two nail holes. It took several applications to get a smooth and even surface. I packed some briar dust into the nail hole with my dental pick and my finger. I wanted the briar dust to fill the holes so I tamped them down with the dental pick. Then I dripped in the superglue to bind the briar dust to the surrounding area. The first photo below shows the top of the rim after briar dust superglue patch has been done.

Image

After patching the nail holes I worked on the stain line around the bowl. I removed the finish from the bowl with a cotton pad soaked with acetone. I continued to wipe it down until the finish was gone. After that I sanded it with a medium grit sanding sponge. The next six photos show the sanding process with the sponge. I also sanded the end cap with the sponge being careful around the CPF stamping that I had found under the oxidation.

ImageImageImageImageImageImage

The dark lines were better after the sanding but still very present. I was able to remove the indentation in the briar from the metal cap to a large degree but the black was stubborn. I decided to soak the bowl in an alcohol bath to see what would come out. I took the shank cap off to work on it while I left the bowl in the bath for about an hour. I was able to remove much of the oxidation on the shank cap. I scrubbed it with the tarnish remover and then sanded it with the micromesh sanding pads using 1500-2400 grit pads.

Image

Once I remove it from the bath I dried it off and the lines were lighter than before. I sanded the bowl some more with the sanding sponge and glued the shank cap on with white glue. I wait to glue it on until I am done with the alcohol and acetone as I found out the hard way the glue is dissolved and has to be redone. After that I reinserted the stem and set up my heat gun to bend the stem to the correct angles. The next four photos show the bending of the stem from its beginning to the final look after bending.

ImageImageImageImage

I took it back to the work table and did some more sanding on the bowl especially working on the surface around the top sides near the rim. The black line was stubborn. I wiped it down with white vinegar to see if it would lift any of the stain as I remembered reading about that in an old book on furniture repair on how to remove dark rings from the wood. I also wet a cotton pad with bleach and wiped down the area as well. The result of all that work is evident in the two photos below. It was not going to come out so I sanded it with 1800-3600 grit micromesh sanding pads and then wiped it down with an alcohol dampened cotton pad to remove the surface dust and prepared to stain it. The two photos below show the bowl ready to stain. (Incidentally note the shine on the shank cap. It cleaned up amazingly well.)

ImageImage

I applied an oxblood thick aniline stain for the first coat. I flamed it and reapplied it and flamed it a second time (the first two photos below show the staining of the bowl with the oxblood stain). I then buffed it off to see what I had to work with. The black lines still showed so I restained the bowl around the top edge to see if I could darken that area and mask the black (photos three and four show this process).

ImageImageImageImage

I buffed it a second time to see where I was at with the staining. You can see from the next two photos the effect of that restaining around the top of the bowl. It did indeed darken the edge but the line was still visible and I did not like the look of the dark edge. So I buffed it yet again to see if I could smooth out that look a bit more.

ImageImage

I was not happy with the finished look after buffing. The darkening around the edge still showed both in the top edge of the bowl and around the end cap. I decided to restain the bowl with a dark brown aniline stain. So I applied the stain, flamed it and restained and flamed it a second time. The next two photos show the pipe after the stain had been flamed and had dried.

ImageImage

I buffed it to see how the second stain had covered the darkening around the top edge and near the shank cap. I was pleased by the overall look now. It was still there for sure but it certainly was less visible and blended in well with the finish. The next four photos show the pipe after restaining and buffing.

ImageImageImageImage

I set the bowl aside and worked on the stem. I sanded it with micromesh sanding pads 1500 – 12,000 grit to polish the stem. I put the stem back in the bowl and then took the pipe to the buffer and gave the entire pipe a buff with White Diamond and then gave both the stem and bowl multiple coats of carnauba. The finished pipe is picture below. It came out very well and the black line around the top edge seems to be less visible. The pipe is restored to a bit of its former glory!

ImageImageImageImage

CPF French Briar Bulldog Restemmed and Refurbished


This morning I decided to start working on one of the pipes that came in the lot of bowls I picked up off of EBay. I chose one of the CPF Bulldogs. It looks to be an old timer. It also looked like it had quite a different look in times past as there were signs of a band on the shank and something around the rim as well. It could well have been the gold/brass filigree that is often seen on these old timers but there is no way of telling for sure. The bowl rim was clean as if once the decoration was removed the briar underneath was raw stain. The bowl itself was also absolutely clean on the inside – taken back to bare briar. Around the inside of the rim there were several small nail holes that looked like they held the rim cap in place. These holes were also on the outside as well though they had all been patched. The shank was cracked and repaired. The repair looks to be old and may well have been under the band that had disappeared. The mortise was originally threaded but that had been drilled almost smooth. I had a stem in my box of stem that would fit with a little work. It was the right size and the angles on the diamond matched those on the stem – a rare feat to be sure. I would not have to do much sanding to bring it fit well. The finish was clean but there were lines on the bowl and the shank from the cap and band. The stamping was clear – CPF in an oval with French above and Briar below. It had a gold paint that had been applied to the stamping and it was very clean. The series of three photos below show the condition of the pipe and the new stem when I began this morning.

ImageImageImage

I asked Robert Boughton about the CPF brand stamp as he is currently refurbishing an old CPF Meerschaum and had done work on the brand. He sent me the following information:
“Chuck (Richards) assigned to me the challenge of finding out what CPF stood for and anything else I could learn… I found conclusive evidence that despite several other names associated with CPF, it indeed stands for Colossus Pipe Factory…Below are the links I sent to Chuck at the time and a few more. But again, it’s nothing Chuck didn’t already know. He also knew it would be good experience for me and that I would enjoy the task! Indeed, I was proud of my findings!”

http://pipedia.org/index.php?title=C…s_Pipe_Factory Bottom of center row of newspaper clip
http://www.google.com/search?q=colos…w=1600&bih=658
http://pipephil.eu/logos/en/logo-c1.html See CPF — includes briars
http://pipesmokersforum.com/communit…ing-one.10858/
http://www.worthpoint.com/worthopedi…pipe-287735110
http://www.smokingpipes.com/pipes/es…oduct_id=74274

With that information in hand, thanks to Robert, I went to work on this older American bulldog to bring it back to life. I had an old nickel band that fit pretty well to the shank. It was shorter than the original band but it covered the repair in the shank. I heated it and pressure fit it to the shank. It was a bit dented and would need to be straightened once it was in place. I then worked on the stem to get it fit the shank and band connection. I used medium grit emery paper to remove some of the vulcanite to get the sides and angles of the stem to match the shank. This had to be done carefully so as not to change the angles. Each side had to have the same amount of material removed to keep the diamond angles even. The next series of four photos show the stem after it has been shaped and sanded to match the shank and the band.

ImageImageImageImage

I cleaned out the inside of the stem as it was very dirty. I had sanded down most of the oxidation and the calcification on the stem earlier but needed to work on that some more. I also used a dental pick to clean out the slot as it was packed tightly on both sides of a small centre hole what was left. I finished sanding with medium grit emery cloth and move on to 320 grit sandpaper to begin to work on the scratches in the stem. The next three photos show the stem after sanding with the emery paper (photo 1) and then the 320 grit sandpaper (photo 2-3).

ImageImageImage

At this point in the process I decided to bend the stem to get the flow of the pipe correct. In retrospect I could have waited until I had polished the stem to do the bend. But I was curious to see the look of the bent stem on the pipe bowl so I set up my heat gun and carried the stem to the gun. I have been using a hardwood rolling pin that my wife discarded as the curves to bend the stem over. I find that using this keeps the bend straight and also gives me the degree of curve I wanted. I adjust the curve by where I put the stem on the pin to bend it. I use low heat on my heat gun and move the stem quickly over the heat about 3 inches above the tip. It does not take long to heat it to the point it is ready to bend and then I lay it over the pin and bend it. I hold it in place until it cools enough to set the bend. The next series of three photos show my set up for bending the stem.

ImageImageImage

I then decided to work on the bowl of the pipe. I wiped it down with acetone on a cotton pad being careful to avoid the gold stamping in the shank. I also sanded the line around the rim and the shank with 320 grit sandpaper and then with 1500-2400 grit micromesh sanding pads to try to minimize the line around both points. I used a flat tip screw driver blade as a smooth surface to hammer out the dents and rough spots on the band. I also laid the shank flat on a board and used the screw driver tip to smooth the inside edge of the band and square up the corners of the diamond. The next series of six photos show that process. I finished by inserting the stem and continuing to smooth out the band.

ImageImageImageImageImageImage

I wiped the bowl down with another acetone wetted cotton pad to remove the sanding dust from the bowl and the rings around the bowl. I used a dental pick and retraced the rings to clean them out as well of previous wax and dirt that catches in those spots. The photo below shows the pipe bowl ready to restain.

Image

Before staining I worked on the stem some more to smooth out the remaining scratches and bring it to a shine. I used micromesh sanding pads from 1500-12,000 grit to bring the stem to a glossy finish. The next twelve photos show the progress shine developing after each successive grit of micromesh sanding pad was used.

ImageImageImageImageImageImageImageImageImageImageImageImage

Once the stem was done I was ready to stain the pipe. I used an oxblood aniline stain to restain the pipe. I applied it with a cotton swab, flamed it, restained and flamed it a second time. The next two photos show the bowl with the oxblood stain applied just before I flamed it. Once I had flamed it I took it to the buffer and buffed it with White Diamond.

ImageImage

After I buffed it with White Diamond I gave it repeated buffing with carnauba wax to protect the stem and the bowl. The next four photos show the finished pipe.

ImageImageImageImage

Dr. Grabow Viking Restemmed and Refurbished


Blog by Steve Laug

In my recent EBay purchase of pipe bowls there was a Dr. Grabow Viking metal base minus the stem. I have had several of the Grabow Vikings over the years and cleaned them up and sold them. I have one that is in my regular rotation and it is a great little pipe. This one came with a Dublin shaped bowl and the shank was not bent or damaged. For a long time now I have wanted to try restemming one of these metal pipes and do a write up on the process. This would be the opportunity to do both. The metal bowl base was coated inside with the tobacco lacquer that is often found in old Vikings or Falcons that have been sitting for a long time unused. The aluminum shank was oxidized and dull but would shine up well with a little elbow grease. The finish on the outside of the bowl was not damaged and would be easy to restore. There was a rough broken cake in the bowl and the rim was tarred and caked. As I inspected the bowl I noted that there was also a burned area on the inner rim at the back of the bowl. The first three photos that follow show the condition of the pipe when it arrived on my work table.

ImageImageImage

My procedure for cleaning an estate pipe is generally the same. I may vary the steps a bit but always cover the same ground in pretty much the same order. On this one I began by working on the bowl. In this case it meant removing the bowl from the pipe. The Viking has screw on bowls that are interchangeable with other Viking bowls (but not with Falcon bowls which have a different thread size and count). I reamed and cleaned the bowl of the old broken cake and picked out the buildup around the hole in the bottom of the bowl using a dental pick. I took apart the base and the inner tube. The tube slipped out easily as it is normally held in place by the stem. I cleaned the tube with pipe cleaners and Everclear and then cleaned out the entrance of the tube into the bowl base. After cleaning that I put the tube back in place. I wanted to plug the hole with it so that I could fill the base with Everclear to soften the lacquer buildup. I soaked it with Everclear and then scrubbed it with cotton swabs once it had softened. The next two photos show the process of cleaning the bowl base and tube.

ImageImage

I sorted through my stem box and found a precast stem for a Canadian. It was a small sized taper that would give me room to work with the diameter and the length that I needed for the right dimensions. I drilled the tenon on the stem blank so that the airway would be large enough to go over the tube at the end of the shank. I turned the tenon with my PIMO tenon turner set to the smallest setting so that I would have little left to remove for a good fit into the hole in the end of the metal shank. The fit involved the tube fitting inside the airway of the tenon and then the tenon itself fitting into the opening on the end of the shank. I used my needle files and emery paper to sand the tenon after I had turned it on the turner. I needed to take it down further for the fit so I used my Dremel with a sanding drum. The next series of seven photos show the process of fitting the stem to the metal shank.

ImageImageImageImageImageImageImage

After I had the basic fit as pictured above I decided to work on the out dimensions of the stem to get a smooth flow between the metal shank and the vulcanite stem. I used my Dremel to take down the majority of the excess material that needed to be removed. The next two photos show the stem after I had used the Dremel. It was ready to hand sand at this point in the process.

ImageImage

I sanded the stem with medium grit emery paper to remove the marks from the Dremel and smooth out the angle of the stem from the shank to the button. I also shortened the tenon to get a tight fit on the stem to the shank. It was just a little too long to fit the depth of the hole in the shank. The next series of five photos show the fit to the shank and the first stage of sanding to remove the scratches.

ImageImageImageImageGrabow under

I took the stem back to the Pimo tenon turner and set it a bit deeper to smooth out the portion that goes against the shank. Then I took it back for more sanding to make it fit more tightly against the shank. I moved on to sand with medium grit sanding sponges to continue to make the stem sit correctly on the shank and to remove the scratches remaining on the stem. The next seven photos show the progress on the stem. It is getting close to a good fit and the scratches are less visible. I also wiped down the bowl with acetone and sanded the top of the bowl and the inside edge of the bowl to deal with the burn mark on the back side of the rim.

Grabow1 Grabow2 Grabow3 Grabow4 Grabow5 Grabow6 Grabow7

At this point you can see some of the minor scratches on the aluminum of the shank. These will come out when I use the micromesh sanding pads after the stem is ready. The next series of two photos show the progress of smoothing out the stem with the micromesh sanding pads. I wet sanded with 1500, 1800 and 2400 grit sanding pads. Each successive grit gave a deeper shine and polish to the stem surface.

Grabow8 Grabow9I also wet sanded with 3200 grit micromesh sanding pads. The next two photos show the change in the stem as the shine deepens.

Grabow10 Grabow11

I went on to dry sand with 3600 – 12,000 grit micromesh sanding pads. The next series of photos show the progress in polishing of the stem. To me the final three grits – 6000, 8000 and 12,000 grit – show the most change. The next two photos are selected to show the progress. The first one below is of the stem after sanding with the 4000 grit micromesh. The second photo shows the stem after sanding with the final three grits of micromesh.

Grabow12 Grabow13Once the stem was polished I used some clear superglue to glue the stem to the shank. I also went on to stain the bowl with an oxblood stain. I applied it and then flamed it and restained and reflamed it. The next four photos show the pipe after staining and before taking it to the buffer. I also used the micromesh to polish the stem and shank.

Grabow14Grabow15 Grabow16 Grabow18

The final four photos show the finished pipe. I buffed it on the buffer with White Diamond and then gave the bowl and stem multiple coats of carnauba wax and buffed with a soft flannel buffing pad to give it a shine.

IMG_0476 IMG_0477 IMG_0478 IMG_0479

Reworking a Dr. Grabow Riviera


Blog by Steve Laug

I am finally down to the last five pipes in my refurbishing box. I have a bunch more on their way here but I would like to finish up this lot before they arrive as they have been sitting here for a long time always getting passed over and laid aside for more favorable looking options. Last evening I decided to rework this old Dr. Grabow Riviera. It was a pleasant shape but an ugly piece of briar. I removed the stem and was amazed that it was a push stem with a well made tenon. The drilling was spot on and the internals were really well done. The draught on the pipe was excellent. The bowl was clean and the drilling in the bowl was nicely done as well with the airway perfectly centered on the back bottom edge of the bowl. The externals however left much to be desired. The first series of four pictures below show the bowl with the many fills that are on the outside of the bowl. These were not tiny fills by any means; in fact the majority of them are quite large. I had to make a decision on whether to refill them or to rusticate the pipe. Last evening I just was not in the mood to rusticate the pipe. Sometimes I just feel like working over a bowl but this was not the night for doing that. So I decided to pick out the fills and rework them with briar dust and superglue and restain the pipe. The stem was in pretty decent shape also – no bite marks or tooth chatter, very clean with a minimum of oxidation.

IMG_0250 IMG_0251

ImageImage

The next series of four photos show the bowl after I have picked out the fills with my dental pick. I actually have a good time picking out the ugly pink putty or as in this case bright white putty. The holes that were filled were not deep but they were on the larger side. Once I picked out the putty I wiped down the bowl with acetone to clean up the mess. I always try to scrunch the cotton pad down into the hole to draw out the last of the putty dust. The worst fill to work with was the one on the back side rim. It was like a saw cut in the rim. It was quite deep and intrusive going from the outside to the inside of the bowl.

ImageImageImageImage

With each of the cleaned out holes I used my dental pick to tamp in briar dust. I try to tamp in the dust until the hole is packed and the dust forms a bit of a bulge on the hole. I find that once I drip in the superglue the dust settles in and the new fill is closes to the surface of the bowl. I also purposely overfill so that I can work to smooth out the fill with sandpaper and blend it into the surface of the bowl. The next three pictures show the patches on the bowl. You will notice the overflow of superglue on the surface of the bowl in the pictures below. This is fairly easily removed as it dries quickly and does not permeate the surface of the bowl.

ImageImageImage

The next series of thirteen photos show the progress of sanding the patches back to the surface of the bowl. In this case I was planning on refinishing the bowl anyway so I sanded the whole bowl back to bare briar. I began by sanding the patches with 240 grit sandpaper and then 320 grit sandpaper. Once the overfill of briar dust and glue was sanded fairly smooth I sanded itwith a medium grit sanding sponge and then a fine grit sanding sponge. I wanted to get rid of the excess fill and also to remove all the scratches in the surface of the bowl. I wet sanded the bowl after this with 1500 and 1800 grit micromesh to ready it for staining. I wiped it down with acetone on a cotton pad. The final pictures show the pipe as it is ready for restaining. You can see that the white putty fills are now dark patches on the bowl. I find that those these dark patches still show up they are easier to blend into the stain and somehow do not seem as intrusive to my eyes as the white patches.

ImageImageImageImageImageImageImageImageImageImageImageImageImage

I decided to stain the pipe with an oxblood aniline stain. I applied it with a cotton swab, flamed it, restained and reflamed it. Once it was dry I hand buffed it with a soft cotton cloth before taking it to the buffer. The next four photos show the pipe after the staining and initial hand buff.

ImageImageIMG_0428 IMG_0429

After staining the bowl I worked on the stem. I sanded it with a fine grit sanding sponge and then worked through the micromesh sanding pads from 1500-12,000 grit. I wet sanded with the first three grits (1500, 1800 and 2400 grit) and then dry sanded with the remaining grits. I took it to the buffer and buffed the stem and bowl with White Diamond before applying several coats of carnauba wax and then buffing with a soft flannel buff. The next series of four photos show the finished pipe. In my opinion the fills look far better than when I first started on the pipe. They now are tolerable in my sight and I believe this will make a fine yard pipe or rotation extender for some new pipe smoker. It is cleaned and ready to smoke.

IMG_0430 IMG_0431 IMG_0432 IMG_0433

 

GBD 9438 Virgin Restoration


Blog by Al Jones

If you have followed my previous posts, you’ve noticed that I am a fan of the GBD 9438 shape. There is just something about the chubby Rhodesian shape that appeals to me. All of the 9438’s in my collection are excellent smokers and feel great in the hand. For the past two years, I’ve been on the lookout for one of the highest grades in that shape, the Virgin. I found this somewhat tattered 9438 Virgin with a Perspex stem on Ebay.

The pipe showed some bruising and nicks on the bowl, but the top looked in decent shape as did the Perspex stem. Photographing details of a Perspex stem is never easy, but this seller had plenty of good photographs.

Below are the pictures posted by the seller.  You can see the handling marks on the bowl in the first shot.

GBD_9438_Virgin-Before (10)

GBD_9438_Virgin-Before

GBD_9438_Virgin-Before (1)

GBD_9438_Virgin-Before (2)

GBD_9438_Virgin-Before (5)

GBD_9438_Virgin-Before (6)

The bowl had a light cake, which I reamed close to the briar with my Castleford reamer. I soaked the bowl overnight with Everclear and sea salt. I use a champagne cork to plug the shank end and try to work a little of the salt/Everclear slurry into the shank.

The stem was in pretty good shape, but had a tooth indention on the lower side and some scratches. I tried to lift the tooth mark with some heat, but the Perspex isn’t as resilient as Vucanite. I removed the scratches with some 1500 then 2000 grit wet 3M automotive grade wet sandpaper. Next I completed the stem work with 8,000 and then 12,000 grit micromesh sheets. I buffed it lightly with some automotive plastic polish. The draft hole isn’t heavily stained, which is a fortunate find on a Perspex stem. The tooth mark is on the bottom and the clear Perspex hides it nicely. (and makes it difficult to photograph)

My biggest concern about the briar was what appeared to be handling pinprick marks in several spots, probably from banging around in a drawer/box for a few decades. Using a torch, wet cloth and a pirated kitchen knife, I was able to lift a majority of the marks. The nomenclature was light, so I carefully buffed the bowl with first White Diamond then two coats of carnuba wax. That helped even out the color and hide some of the bruising. It’s not perfect, but has a nice level of patina.

GBD_9438_Virgin_Finished (6)

GBD_9438_Virgin_Finished (1)

GBD_9438_Virgin_Finished (2)

GBD_9438_Virgin_Finished (3)

GBD_9438_Virgin_Finished (4)

GBD_9438_Virgin_Finished (5)

GBD_9438_Virgin_Gallery

With this addition of this Virgin, I now have five different grades of the 9438 shape.

Fantasy

GBD_9438_Fantasy_Gallery 3

Tapestry

GBD_Tapestry_9438_2nd_Gallery

Prehistoric

GBD_9438_Prehistoric_Gallery

New Standard

GBD_9438_New_Standard_Gallery

I include this Seventy-Six Colossus as it is an oversized 9438 (stamped 9676) and clearly the 9438 chubby Rhodesian shape.

GBD_Colossus_76_Gallery

Repairing a Stem on a Dr. Grabow Grand Duke with Black Superglue


I took on this project to demonstrate how I use black superglue to repair deep bit marks/bite throughs on vulcanite stems. I had this old Grabow stummel in my box and I found a stem that looked good on the bowl. The bowl had a small hairline crack in the shank so I pressure fit a band on it for a repair. The bowl needed to be topped so I did that after banding. I restained the top to match the bowl colour. I used a dark brown aniline stain that I mixed with isopropyl alcohol until I got the match I was looking for. I stained and flamed the rim to set the stain. The stem was in pretty rough shape but I decided to use it anyway and take it on as a project. The button was almost gone from the deep bite marks. There were three bite marks on the underside of the stem near the button and on bite mark on the top of the stem. I decided to use the boiling water trick to try to raise the dents as much as possible. These were deep bite marks and the edges were rough so my guess was that they would not come up to the surface with the heat. I then sanded the surface of the stem with medium grit emery paper to remove the surface marks and dents and then smooth out the area of the deep bite marks. I work to have a semi rough surface for the superglue to bond with so I am not sanding it smooth as much as working it over to make it clean. The next three photos show the state of the stem after I had sanded it and readied for patching.

ImageImageImage

Once I had sanded the surface smooth I used my needle files to recut the sharp edge of the button and rework the flow and angles of the button. I also used the needle files to carve the surface of the stem and provide a gentle slope to the new button area. I have found that often when recutting the button and defining its shape it is easy to cut a trough and make a hump in front of the newly shaped button so I always start about half way up the stem and use the file to change the taper to flow to the edge of the button. This served the dual purpose of removing high spots on the bite marks and to help identify the actual holes that would need to be patched. The next two photos show the file work on the stem.

ImageImage

Once I had the slope correct and the button shaped I put the stem in the ebony block I had drilled with a mortise to allow me to sand the rest of the stem without rounding the shoulders of the stem. I wanted the stem shank junction to be smooth and well fit. I also wanted the oxidation removed from the stem before I patched it with the superglue. I did not want the oxidation to remain in the holes that I would patch or on the surface of the stem. I sanded it down and removed the oxidation. I spent extra time around the bite marks. I also picked out any loose debris in the marks with a dental pick and then wiped it down with alcohol to remove the dust and provide a clean surface for my patch work.

ImageImageImage

The next series of three photos show the patch in place. I use black superglue that I pick up from Stewart-Macdonald http://www.stewmac.com/shop/Glues,_adhesives/Stewart-MacDonald_Super_Glues.html I have found that it really works well. I drip it on the cleaned hole and make a bubble of superglue. This particular glue dries slowly so I do one side of the stem at a time. I let it dry for over an hour before turning it over and doing the same thing on the other side of the stem. Once I have made the patch I set the stem aside to dry overnight. I do not want to touch it or sand it until it has had that time to cure and become hard. I have tried sanding sooner but always end up patching the holes a second time because of my impatience.

ImageImageImage

Once the glue has cured and is hard it forms a small bubble of black on the surface of the stem. I sand the bubble flat to the surface and taper of the stem. I use a 320 grit sandpaper to accomplish this sanding. At this point in the process I am not looking for shininess or polish I am only trying to blend the patch into the surface of the stem. The next five photos show the process of sanding down the bubble and the look of the resulting patch on the stem. The tooth marks are gone and in their place is a black patch that with a bit more polishing and sanding with micromesh will blend into the stem well and give a new polished look and comfortable feel to the stem.

Image

The underside of the stem. Notice the patch near the button after sanding with 320 grit sandpaper. The patch on the underside is larger than the one on top but it not as deep.

Image

The bubble of black superglue on the top of the stem. The white dust on the stem is not a problem as the bubble is dry at this point and ready to sand.

Image

The top side of the stem after the initial sanding of the bubble. It is almost smooth and needs to be wet sanded with the micromesh sanding pads.

Image

Top side of the stem after the patch has been wet sanded with 1800 grit micromesh sanding pads.

Image

The top side of the stem after the patch has been wet sanded with 1800 grit micromesh sanding pads. There are still scratches that remain in the stem on both the top and the bottom that more sanding will remove. The patch will also blend in better as the stem itself begins to shine.

The next series of photos show the stem as I sand it with the various grits of micromesh sanding pads. Between the 2400 and the 3200 grit sanding pad I scrubbed the stem with Maguiar’s Scratch X2.0 to polish out some of the remaining scratches.

Image

The top side of the stem after wet sanding with 1800 grit micromesh sanding pads.

Image

The underside of the stem after wet sanding with 1800 grit micromesh pads.

Image

The top side of the stem after wet sanding with 2400 grit micromesh pads. The patch is beginning to be harder to see on the surface of the stem.

Image

The underside of the stem after wet sanding with 2400 grit micromesh pads.

Image

The top side of the stem after I polished it with the Maguiar’s Scratch x2.0. The patch is blending in very well on the top side. If you did not know where it was it would be hard to see.

Image

The underside of the stem after polishing with the Maguiar’s. The patch is also beginning to blend in very well on this side of the stem as well.

Image

The top side of the stem after I had dry sanded it with the 3200 grit micromesh pads.

Image

The underside of the stem after dry sanding with the 3200 grit micromesh pads.

Image

Topside of the stem after sanding with 3600 and 4000 grit micromesh pads. The patch is virtually hidden to the camera at this point as the stem begins to shine.

Image

Underside of the stem after sanding with 3600, 4000 grit micromesh pads.

Image

Top side of the stem after sanding with 6000, 8000 and 12,000 grit micromesh pads.

Image

The underside of the stem after sanding with 6000, 8000 and 12,000 grit micromesh.

The next series of four photos show the finished pipe after buffing with carnauba wax and a soft flannel buff to give it a shine. The pipe is restemmed, repaired and ready for it next smoke.

ImageImageImageImage

 

Cleaning Up an Interesting Dr. Bernard Deluxe System Pipe


When I initially took this one out of the box I figured it would be an easy cleanup. It did not turn out that way. It is stamped Dr. Bernard over de Luxe on the left side of the shank and on the right side it is stamped ALGERIAN BRIAR over France and that is stamped over Made in France. The first two lines were not lined up and they are actually on top of the made in France line. The finish looked pretty clean and the bowl and rim were also clean. The stem was lightly oxidized and had a stamp on it that says Dr. B. It also had a little tooth chatter near the button on the top and the bottom of the stem. The first four photos below show the pipe when I started.

ImageImageImageImage

The worst thing on the exterior of the pipe was a large fill, about the size of the end of my thumb. It stood out in all of it pink putty look each time you held the pipe in your hand. It is clear in the photo below. I thought about rusticating the pipe but decided that with a fill that large I would be better off leaving it alone. I would have to work on it to try to blend it in a bit better with the stain on the bowl.

 

Image

I decided to address the tooth chatter and oxidation on the stem first. I sanded the tooth chatter with 320 grit sandpaper to remove scratches and marks. The first two photos below show the tooth chatter removed and now the stem would need to be sanded and polished. The next series of four photos show the filter apparatus in place and after I took it apart to clean it. I then removed the stem from the shank, cleaned out the shank and examined the filter apparatus on the pipe. I removed the cap from the end of the filter and underneath was a metal tube inside the shank. I cleaned the stem with pipe cleaners and isopropyl alcohol and then cleaned the cap with cotton swabs and isopropyl. Once it was clean I polished it with 0000 steel wool to give it a shine and remove the stains on the metal. I also sanded the stem with a fine grit sanding sponge to begin to remove the scratches and oxidation.

ImageImageImageImageImageImage

I went back to the fill on the bowl. I decided to draw in some graining on the fill that matched the grain surrounding it using a permanent marker. I have done this in the past and it allows you to blend the stain on the bowl and mask the fill so it does not stand out as much.

Image

After drawing on the grain pattern I stained the bowl with an oxblood stain. The first photo below shows the finished look. Once the bowl was dry I buffed it on the buffer and the stain coat wiped off in major chunks. It did not permeate the bowl at all. I also was able to wipe of the grain pattern I had drawn on the pipe. This kind of frustrating occurrence while cleaning up a pipe is just part of the process. I cleaned off the stain with a cotton pad and acetone and then noticed that the pipe had been given a very thin coat of varnish (matte finish) over the bowl. I would need to remove this finish in order to restain the pipe. So back to the table it went.

Image

I wiped down the bowl with acetone until the varnish coat was broken and then sanded the bowl with the fine grit sanding sponge to remove the remnants of the finish and get back to the briar itself. The next three photos show the cleaned bowl. The large fill on the back side of the bowl is also very clearly visible. I then redrew the grain marks on the bowl with the permanent marker to blend in the fill a bit more. In the fourth photo you can see the lines drawn in. They may appear to be too many and too dark at first look but I have learned that once I have stained the bowl with a few coats they will dissipate into the stain and will match the grain pattern in the bowl.

ImageImageImageImage

I worked on the stem and used the micromesh sanding pads from 1500-12,000 grit to polish the stem. I coated it with Obsidian Oil and set it aside. I restained the bowl with aniline based oxblood stain. I applied the stain heavily to the area of the fill. I flamed it and them polished it on my buffer. The next six photos show the restained bowl. The stain took this time. It also covered the fill but the lines were still to visible to my liking. I needed to add some more stain and let it dry this time without wiping it off or buffing it. I needed a bit more opacity in the stain on this portion of the bowl.

ImageImageImageImageImageImage

So I applied some more stain with a cotton swab to just the fill portion of the bowl. I set it aside to dry overnight and in the morning hand buffed that area of the pipe. I hand buffed with a shoe shine brush and a soft cotton cloth. Once I had finish I buffed it lightly with carnauba wax multiple times to give it a protective coating. The final four photos show the finished pipe. The fill is much more blended into the stain coat and the lines are there but more subtle. The fill is not as glaringly staring at you while you hold the bowl. The pipe is ready to smoke and for me to experiment with the interesting filter apparatus.

ImageImageImageImage

Jichimu Wood Pipes – Robert Boughton


中國雞翼木頭

Jichimu Wood Pipes –  Guest Blog by Robert M. Boughton

“I think there should be collaboration, but under my thumb.”

—Elia Kazan, 1909-2003, Movie and Stage Director

Introduction

All jokes aside, however waggish, every successful endeavor in life, from beginning to end, involves collaboration.  I emphasize the word successful since, of course, Man has free will as a prerogative and always, therefore, the choice to go it alone – to be able to say at the final moment, as Frank Sinatra rejoiced in song, “I did it my way.”  As a writer, for example, I may be competent, but even Ernest Hemingway had Maxwell Perkins as his brilliant editor for most of his literary career, and Elia Kazan (quoted above) directed such movie titans as Marlon Brando, Vivien Leigh, Gregory Peck and on multiple occasions Karl Malden, all of whom had something to do with their two-time Academy Award-winning master’s ultimate success.  The word collaborate, from the Latin co for together combined with laborare, meaning, as one might guess, to labor or work, also has a negative connotation.  The four-year French Vichy Regime’s coöperation with the Nazis during World War II, in which certain French military and civilian leaders surrendered to Germany in exchange for a deluded pretense of self-government without such details as a new constitution, comes to mind.  Yet the same negative collaboration of these traitorous Frenchmen led to the positive sort, including the infamous underground Resistance Movement, and in turn became instrumental in the Allied invasion of Normandy and the ultimate liberation of France.

If perhaps on less historic and adventurous levels, most of us, throughout our lives, seek the help and experience of friends and even the kindness of strangers, so the concept of collaboration came easily to me.  I long ago learned to ask questions when I did not know the answers.  Again, I emphasize the phrase for the most part: my dear dad, who is still with us, is a genius and by consequence a fount of enlightenment on at least a passable level in almost every study of human knowledge (except literature, which when brought up created an odd defensiveness in the man).  While he was happy to explain to me in detail diverse topics — including what makes the sky blue, the technical elements of Old Master paintings, the rudiments of handwriting analysis, the basic design and operation of a combustion engine and the concept of imaginary numbers — for definitions or spellings of words or synonyms and antonyms, my father in his own inner crucible reached critical mass when I was about 13 and started referring me without hesitation to his huge, old, worn editions of Webster’s Unabridged Dictionary  and Roget’s Thesaurus until I learned to seek them out myself.   Of course, I did not much care for my dad’s well-meaning if snarky habit of advising me to engage my brain before my mouth, but I am grateful nevertheless for the gift of research he taught me.  Now I prefer my own complete Oxford English Dictionary and the Oxford American Thesaurus or a great online alternative for the latter.

To be honest, though, for most of my life I have been the one doing the majority of seeking of knowledge from other people, whether asking outright or trying to get the desired information in a more oblique manner, or as a writer employing my powers of observation to study the characteristics, voices and other nuances that raconteurs everywhere simmer together in their stories.  And so I had an uncommon, almost uncomfortable, tingle of pride when the refinishings and restorations of the two jichimu churchwarden bowls that are the topic of this blog were complete and I asked Chuck Richards (my fellow local pipe club member and the master restorer responsible for the main work on one of the pair}, with all sincerity, what I could have done better to prepare and wax by hand my project – and his reply was, “Absolutely nothing.”   Then, just this past month, Chuck gave me a real loop at our club meeting when he began to speak about a 19th century Colossus Pipe Factory (CPF) Best Make, real gold-banded, amber-stemmed, turned bowl lion’s head Meerschaum he had acquired in trade and mentioned that he had a challenge.  After he unveiled the damaged but gorgeous golden Meer and passed it around the room for all of us to adore, and suggested that the details of its maker were a mystery to him, Chuck smiled and revealed that the challenge was for me to take the invaluable CPF home and see what I could dig up online about its origins.  To say the least, I was dumbstruck by Chuck’s trust in me.  To be more specific, I was honored beyond words that he wished to collaborate again on a different project than that which I will soon begin to address.  Maybe I’ll get back to the CPF another time.  By the way, I didn’t find much online that Chuck didn’t already know.  The exercise was only a test he knew I would enjoy.

jichimu1

Robert M. Boughton,
Photograph © Robert M. Boughton

jichimu2

Chuck Richards.
Photographs © Robert M. Boughton

Jichimu Wood, and a Note on One Pretender

Jichimu, or 中國雞翼木頭 (the literal translation of chicken wing wood), is a beautiful, unique, porous wood named for its tight, feathery quality resembling the wings of some chickens or pheasants that can change in color depending on the lighting or different angles of view.  Thus it has come to be known in common language as chicken wing or phoenix tail wood.   The estimation of this hardwood as one of China’s three most valued materials for antique furniture and other craft work is unequivocal.

jichimu3There are, in fact, two kinds of jichimu: old and new.  The old variety, being denser and purplish-brown, when cut straight allows for the magnificent patterns described above.  The new growth has purplish-black, straight, unclear grains (some purple, others black).  The wood is coarse, straight and rigid and therefore apt to split.  It is of the old jichimu that our refinishing and restoration projects are concerned.  The use of jichimu in royal furniture appears to date to the Ming Dynasty (1368-16jichimu444) and to have ended in the mid-Qing Dynasty (1644-1911), and although old jichimu still existed, it reportedly was replaced in woodworking in general by the new variety and other woods at the same time.  This explains why my chancing upon not only one but two virtual twin old jichimu churchwardens –they themselves being rare specimens of this type of pipe making – was, to say the least, fortuitous.

jichimu5

Jichimu pipe.
Photograph courtesy of and © Steve Laug.

While the most common use for jichimu isfurniture, in particular antique, just a few other items made with the favored and rare wood include chopsticks, bows for classical stringed instruments such as violins and cellos, iPhone cases – and, of course, smoking pipes.

jichimu6

African Wenge Pipe.Photo © Robert M. Boughton.

Now for a special warning about certain smoking pipes that are being advertised on Websites such as eBay as Chinese Chicken Wing Wood, of the genus Ormosia henryiAt least in most cases, these pipes (which appear authentic in almost every way) are in fact made of Wenge wood, a similar-looking but lesser-quality for pipes African genus (Millettia laurentii).  While still made from a very exotic wood, Wenge pipes lack the richer coloration and attributes more suitable for durable smoking pipes.  I found out the hard way: I bought one on eBay from a dealer in the People’s Republic of China with an excellent reputation, but I cannot bring myself to gripe at the total cost of $14.62 including free shipping. When the pipe arrived early, I noticed the Wenge marking on the right side of the pipe and thought it must be the maker or location.  Imagine my surprise when I Googled the name and came up with the truth.  Still, the Wenge smokes well and is one odder pipe for my collection, as well as a great conversation piece.

How Two Old Wood Jichimu Churchwardens Found Me

A funny thing happened during a trip to my local head shop a few years back, where I was, alas, well known.  No, I was not a patron of the establishment for, shall I say, its illicit wares.   In fact, although I am reluctant to admit the truth in so public and permanent fashion, I must, in order to clarify the reason I believe these two all but twin jichimu bowls found me rather than the other way around, make this digression.  You see, I found myself these years ago in this fine example of everything a well-rounded head shop should be, however rebuked its sort as a whole, after I had for the most part begun buying all of my pipe necessities at my local tobacconist.  But that night, I was in desperate need of pipe cleaners, which I knew the head shop just around the corner from where I lived carried, and my regular source had been closed for almost two hours.  What was I to do?

Of course, without a qualm I rushed to my car, risking a boondoggle because of the nefarious nature of my neighborhood (known in Albuquerque as the War Zone thanks to its high rate of violent crime).  I made my zigzag dash through long blocks of murky streets, slowing for multiple speed bumps and making a Byzantine course around all of the road barriers – these obstacles being in place to aid police in the apprehension of armed robbers and other dangerous felons – and in this fashion accomplished my mission through the free fire zone that would have taken a mere three block walk straight down my street and a brief jog across Route 66 had I been willing to risk a more than possible firefight with unknown strangers and perhaps even having to shoot the drug-addled ne’er-do-wells in this wild southwest Stand Your Ground state.  At any rate, I arrived intact at the head shop and was greeted as a friendly by the night crew despite my several-month absence.  As I told them what I needed, however, out of the corner of my eye I noticed in the glass case that the shop’s former meager stock of tobacco pipes had increased, and for the better.

Suffice it to say I was compelled to have a look, and the result was love at first sight, or at least lust, for the huge, thick, lustrous bowl and that which I could see of the apparent wavy lines of grain alone.  The stem itself appeared to be of shiny black Lucite and crafted with intricacy that included a wider, beveled round base section that then tapered and curved upward into the bit.  But the bowl – well, the bowl on its own merits had an intoxicating, alluring effect on me.  As a whole, the pipe I beheld was one of the most curious looking churchwardens upon which I had ever laid eyes.  The extraordinary pipe, with its ample bowl (1-3/4” x 2” outer and 1-1/4” x 1-3/8” inner), five-pronged head and shiny dark reddish although perhaps overdone coating seemed almost a fantastic contrast to the typical, more Elven-style churches in fashion.  Upon caressing and inspecting the pipe, which I was amazed to find could accommodate my index finger almost to the second joint with wiggle-room, in part by instinct I concluded $30 was a no-brainer.  At the time, the idea that the type of wood from which the pipe was carved would ever prove to be anything but briar never even occurred to me.

I must admit at this point that I was surprised not only when the stem broke but by how little time I had to enjoy my new churchwarden, which turned out to be quite a good smoker, before the sudden and catastrophic damage occurred without even any warning.  One minute I was sitting at my computer and smoking the church; the next, the stem snapped, and by chance I caught the bowl between my legs on its way to the hard tile floor.  Although every instinct in me opposed the idea, I had some Super Glue on hand and considered re-connecting the stem until I discovered not two but three pieces were involved, two large and one very small and jagged – and that they were cheap plastic.

Thinking without much hope that the head shop might have a spare stem on hand, and not knowing at the time that I could order a good one online, I returned whence I purchased the original.  Not to my surprise, the shop did not have a replacement for the stem except, to my astonishment, in the form of another, near twin version of the original product intact.  With some trepidation (after all, $30 is nothing to throw away, and I still was in the dark about the rareness of the wood from which each pipe was carved), I surrendered to the clerk’s laid-back upsell, despite my nagging suspicion that even in a head shop there existed a drawer, cupboard or box somewhere in the back area that contained a plethora of exchanged, discarded or otherwise abandoned samples.  Still, deep within the left side of my brain as I bought the whole pipe again – this one of which had but the slightest darker grains along the front and back of the bowl – was the idea that I might at some point locate suitable stems for both and sell or trade one of the two atypical churchwardens to an appreciative aficionado.  As an afterthought, I even went so far as to scrutinize the new stem for cracks or other imperfections.  In short, because of my original trip to the local head shop for some tobacco pipe cleaners and subsequent additional purchase of one still-unidentified jichimu churchwarden, the stem of which soon broke calling for another visit to the shop hoping only to find a stem, I ended up with two old wood jichimu churches.  Sure, I believe in coincidences, but this was too much.

I hope by now you can foresee the next part.  After a few satisfying smokes of the new pipe – in fact, just enough to break in the bowl – the prior misadventure was revisited.  Through neither any fault of my own nor evident structural flaw, did the stem just break again in mid-smoke, and what was more, showed eerie signs of interference by way of the three pieces I located just as in the previous incidence.  I am sure anyone reading this will either think me outright mad or be able to imagine why my thoughts turned to the notion, however uncanny, that perhaps I was not meant to smoke these pipes for preternatural reason(s) unknown.  At times simple anger is the best natural response, however, and with that in mind I tossed both of the then useless bowls and the bottom half of one of the 9mm stems into the glass jar of the only stand I had at the time, a little nine-piper I found at a garage sale about 23 years ago.  There the two ever-alluring disembodied heads, as it were, would stare out at me from time to time with their come-hither looks.

Early Collaborative Restorations

jichimu7

La Grande Bruyère Before. Photo © Robert M. Boughton.

jichimu8

La Grande Bruyère After. Photo © Robert M. Boughton.

Around that time, although I’m not at all sure of the date, I began dabbling in refinishing pipes.  I started with a La Grande Bruyère mini made in Czechoslovakia that I bought – again at a garage sale – sometime in the late 1980s and never smoked until one night when I took it out and examined it with a magnifying glass to make out the brand and decided to clean and try it.  To my surprise, it was a wonderful smoke.  So I carefully stripped all of the tacky red varnish and uncovered a beautiful dark grain.  I continued sanding until the tiny pipe was baby smooth, then took it to Chuck and asked how much wax would cost.  He just said “Give it here,” which I did and proceeded to the pipe shop’s sitting area.  Five minutes later he motioned me over.  I was shocked but very pleased to see that Chuck had waxed it by hand, and the transformation was spectacular.

I had several old Italian no-names from my early days of pipe smoking (I started in 1989) that had serious blackening along the rims of the bowls, some moderate to nasty dings and most of all coatings which offended me so much that my perhaps most basic nature made me wonder what lay beneath.   You see, I’m curious that way.  I winged it again, but in the mean time I bought a small jar of Halcyon II Wax to finish them.  Although I later learned that type of wax is best for rusticated pipes, it ended up working just fine on my three natural finish experimentations.  I ended up giving all three no-names to cigar-smoking friends who were interested in pipes, and by doing so won them over, at least in part.  They really only needed a nudge.  I kept the La Bruyère for myself.

The Jichimu Restores

At last, I arrive at the tale of the restorations of the jichimu churchwarden bowls, one wholly by Chuck after my refinishing of it and one by me except for a final quick machine buffing as I do not yet own the proper equipment.  Because of the broken stems, these two restorations were the first I had encountered on my own that were borne of true necessity, other than what I have heard of the backgrounds and solved problems with the many beautiful restores I have had the pleasure and good fortune of buying from Chuck, although, as the next photo shows, the coatings were real horrors.  I suspect some sort of polyurethane glaze was used in the originals, thereby inhibiting these beautiful pipes’ ability to breathe, a crime I deem unforgiveable due both to the rareness of the old jichimu wood I liberated with my loving if strenuous sanding and that wood’s natural  porousness.

jichimu9

Jichimu pre-restore. Photo © Robert M. Boughton.

This was the bowl I handed over the counter to Chuck at our favorite tobacconist, hoping (and therefore having even a little doubt, which of course proved silly) he could identify its dark reddish, feathery wood.  The master restorer took the large bowl from me and, with the briefest squint behind his eyeglasses, through which I noticed a sparkle of slight amusement mixed with a subtle but unmistakable distaste, said:

“It’s Chinese Chicken Wing Wood.”

I remember the slight sting of what I perceived to be a note of contempt in his pronouncement, however well contained and no doubt unintended, as I paused before asking, “Is that good or bad?”

“It’s neither good nor bad,” Chuck said in his baritone voice and shrugged in this enigmatic way he has.  “It just is.”

Now, I swear to the truth of this next part upon all that is holy to me, which by the way is considerable: I will never forget flashing back to the iconic ‘70s TV series “Kung Fu,” with David Carradine as Kwai Chang Caine and Keye Luke as Master Po, and Chuck was Master Po snatching the pebble from my outstretched palm – again!  Being unable to maintain the absurd private response to an innocent comment in no way intended to insult me, I recovered myself and grinned.  I later learned (by doing the unimaginable – asking Chuck)that his primary concerns about smoking a Chinese Chicken Wood Wing pipe were the possibilities of toxicity and what he considered to be likely high maintenance to keep the pipes undamaged because of their soft, porous nature.  I was unable to find any negative toxicity information for the jichimu wood genus (other than the serious dangers involving any kind of wood dust inhalation), and as for maintenance, I treat the restored jichimu I kept for myself with the same respect I afford any of my other fine pipes, such as my Meerschaums and Peterson’s: in this case, by storing it in a pipe box.

At any rate, Chuck examined the bowl I wanted to keep for my own use and, of course, with his quick, keen eye noted the crack in the top of the shank’s stem opening.  Knowing far less then than I do now of pipe restoration (which remains little), I suggested covering it with a metal band of some sort.  I recall being so proud of that idea!  Chuck, being diplomatic, said that indeed would be part of the solution, but the real problem was finding the right type and color of wood from which to shave enough particles to mix in some sort of Super Glue concoction.  Again I made a suggestion, this time redwood, a small piece of which I happened to have on hand at my home.   Chuck thought about the idea for a second before telling me to bring the wood to the shop for him to check out, but there was no hurry because he would have to do the restoration after the holiday store sale madness and pressing personal projects were behind him.

Meanwhile, I prepped the bowl with considerable sanding and buffing by hand, work I later realized at best made Chuck’s task a tad easier in that he would only have to spend a minute or so doing the job properly on his electric wheel.  The hand sanding and buffing I chalked up to valuable experience (as well as being relaxing and pleasant activities), and should be tried first by all refinishing or restoration beginners, just as anyone new to but serious about photography should start with an older standard SLR film camera to learn the true elements of the art form, including developing the film and printing photos in a dark room, before moving to digital and mastering the dubious practice of Photoshopping on a PC.

jichimu10

Ashley at meeting. Photo© Robert M. Boughton.

Seldom since I was a child had a holiday season seemed to take as long to pass as this last one.  In fact, I had a certain pleasant and childish giddiness and anticipation about Chuck’s restoration of my cherished Chinese churchwarden.  I kept myself distracted with my own restoration of the second jichimu bowl, of which I had already determined to make a gift to a young lady who attends our weekly pipe club meetings as often as work allows (she has, I believe, three jobs).  Ashley has two distinctions in our club, one being that she is the only female member and the other that she smokes churchwardens exclusively.  Who better to give a pipe which, although I knew it would be a lovely specimen by the time I was finished with it, nevertheless amounted to a twin of one I owned? Since Ashley is married to another pipe smoker and club member, Stephen, the gift was platonic in its intent, but still I was careful to broach the subject with him one night when I found him by himself by asking if he thought his wife would appreciate not only the idea of the gift but, of more importance to me, the unusual wood.  In fact, I put it bluntly, would the jichimu be something Ashley enjoyed smoking?  I admit I was relieved when Stephen assured me she would love it, and I asked him not to tell her anything about my plan.  Stephen was more than willing to go along.  I even completed a “first draft” of the restore during this time.

jichimu11

Photo © Robert M. Boughton.

Meanwhile, back to Chuck’s restoration work, after the holiday crush at the shop:  he’d had time to mull over the ideas that took time to come together in his head for this project that, for personal reasons we have never discussed but have become apparent to me in the intervening months, somehow meant more to him than the average restoration.  Somehow none of the rarest, most damaged pipes presenting Chuck with the kinds of severe tests of his masterful skills that he had needed to employ in the past and will continue to utilize in the future seemed more important to him than the simple job I had asked him to perform with my well-sanded and unblemished (other than the small crack in the shank) jichimu bowl I had entrusted to his care.  After all, I had only expected him to fix the crack, wax and buff the bowl on his electric wheel, add a nice-looking metal band of some sort and top it all off with a good stem, preferably of a reddish colorized Lucite variety if he could find one.  And of course I expected to pay for it, although he made it clear in the beginning he would cut me a deal.

The key difference between what I wanted from Chuck and how he approaches any job, I soon came to understand, was in Chuck’s great expectations.  While I expected Chuck to have a fast and easy job of making my bowl look as beautiful as I thought it could be and at the same time able to smoke with the addition of a stem, his ideals are far higher than that.  When at last he began to fill me in on his plans for the pipe – such as the fact that he had found a better match of wood for shavings to fill the crack in the shank than the redwood I had left for him a couple of months earlier, and that they were from an empty cigar box he found in the back of the shop – I discerned in his eyes an excitement I had never seen there before.  That, believe it or not, was my first clue as to how seriously Chuck had taken this “job.”   He explained in detail the process by which he would fill the crack and then attach and seal the band and would add only that he had found “the perfect” stem of which he was certain I would approve.  Of course, since the bowl was a churchwarden and that was the type of stem I had requested, I assumed that was what it would be.  But Chuck, being in charge, had far grander designs in mind.  I have to wonder who was the true child at Christmastime.

So, to cut to the chase as it were, I was sitting at home late one afternoon checking my emails when I found one from Chuck that read, as I recall, “Well, are you ready to come get your pipe or not?”  I must have re-read that brief message several times, shaking with excitement, before picking up my phone to call the shop and make sure he was there.  He was, and his laugh could not disguise his own excitement.  So, telling him I would be right there, I fumbled a few jars of tobacco together and was out the door in a flash.

When I arrived maybe 15 minutes later, Chuck was literally glowing, his face beaming with anticipation and a certainty that I would be satisfied.  Still, I have a feeling that deep inside him was a fear of possible disappointment on my part that had to be utterly alien to him.  Here is what he unveiled to me:

jichimu12

Chuck Richards Jichimu Restore. Photo © Robert M. Boughton.

Need I say I was, for lack of any more suitable a word, stunned by the work of art Chuck had created from my once shellacked and smothered but promising jichimu bowl?  As I recall, in fact, I went a little fuzzy in the head and had to concentrate on not swooning, a very rare reaction for me.  At first I was even speechless, for whatever I had expected from Chuck based on the simplistic guidelines I had suggested, he had, it was obvious, ignored in favor of his own better instincts.  As a result, instead of giving me a new and improved version of the original churchwarden, Chuck had embraced the ultimate spirit of the term restoration, bestowing upon the lone bowl a new life that combined both elegance and even a better sense of Chinese style than any churchwarden ever could have accomplished.

“Well, do you like it?” Chuck said after I stood there gaping a tad too long, and I snapped out of my reverie to look at him, my face flushed with gratitude.

“Are you kidding?” I replied.  “I love it!  It’s better than anything I imagined!”

So of course the time had come for the vulgar but necessary formalities of payment arrangements, but Chuck was already prepared with an itemized bill.  Scribbled on a small paper napkin which he slid forward across the counter were three lines of chicken scratch I had to squint at and read everything for context to realize formed the names of his three favorite tinned tobaccos.  At that point I was sure he was having fun with me, and said so, but he was serious.  In exchange for the hours of loving labor Chuck had invested in this project, not to mentions parts, all it was going to cost me was maybe $55.

And so I returned to my project and set about re-doing the preparatory process of stripping down the bowl I had already sanded, buffed and even hand-waxed.  Somehow, taking a much closer gander at the bowl after deciding I wanted to make a special gift of it to someone who possesses an acute appreciation for fine churchwardens, my earlier perception that the only addition the bowl still needed was a decent stem went out the window.  All I can think now is that I must have been blinded in my rush to the finish line.This, I suspect, is a common urge among restorers.There were still dark, even scratchy, areas on the front and back of the bowl where the grain, I was certain, could show with still more brilliance.  Although I had been told by someone in my pipe community that the direction of sanding did not matter, I recalled something I had seen on TV’s original NCIS.  The episode had a scene where some suspect was working on his yacht, sanding the beautiful wooden deck, and Gibbs (who had his own never-ending boat project) acknowledged that the man was doing it the right way – “always with the grain.”  Plus I remembered the same advice from my father, who is also an expert at carpentry.

Then, suddenly, after stripping the new-old coating from the bowl with coarse paper, I switched to a finer grade and began on the front of the bowl with sure, steady strokes following the grain where it turned upward a little.  After a short time, I cleared off all the fine dust, and gazing at the beautiful, much more even and feathery lines I had set free, felt that warm, glowing reward only someone who works with his hands on anything with potential to be better and succeeds at his task will ever understand.  As if in a trance, I kept at it until my arm ached, and when I was finished with the front let my enthusiasm carry me onward to the backside, which responded with equal elegance.  Admiring the reborn pipe bowl, I was satisfied at last that it was in all truth ready for buffing.  This practice has its detractors, but I like to use fine steel wool for the final gentle buff, being extra careful, of course, to remove the entire resulting metallic residue with a dry cloth.  With that done, I was ready to apply my wax sparingly with a finger until the entire outer bowl was covered.  Giving it time to dry, I wiped it smooth and clean with a soft cotton T-shirt that was too old and small for me to wear and ended up repeating the wax step once more.

After cleaning and sterilizing the bowl and shank with alcohol, I knew that was the best I could do– again, I pined for an electric buffing wheel – and had only the long black Lucite stem Chuck had given me on which to sand down the tenon to fit the shank of the bowl.  That was all I needed to do, he said, suggesting the job would be easy.  Indeed, with an electric wheel it would be, but with the tools I had at my disposal – such implements of potential destruction as sandpaper and a wood file – I harbored, to use a nicety, misgivings.  After all, I know my limitations and am almost always first to admit them, which I will now prove.   Trying to sand down the tenon by hand got me nowhere, so I switched to the wood file.  Now, there are mistakes, and then there are total write-offs.  Within just a few seconds’ time I found myself staring in horror at the resulting apparent near mayhem I had perpetrated upon the unfortunate, innocent opening end of the tenon.  Even after sanding the mangled, tapering pooch-job I had made of it, I still was left with only a smooth (if such it could ever be called again) version of the atrocity that reminded me of every time I ever tried to use one of those electric head grooming sheers on myself – you know, the kind with which barbers go to school to learn to operate on complete strangers with enough skill that they won’t be sued for the results but that are offered in stores in cheaper versions guaranteed to be so easy to do it yourself, only you can’t sue yourself for the one gaping bald gash that always results sooner or later and leaves no option but to shave off all the rest to make the disaster even.

Luckily, I had two things going for me: 1) I knew when to quit for the night and pray that Chuck would be at the store the next day for more of that collaboration, and 2) Chuck had given me a stem with a tenon so long I could afford one screw-up, even after I had already clipped off about a half-inch of the excess.  I knew Chuck was going to tell me I had to get rid of the evidence of my muddled first attempt at stem fitting the same way and at least had the courage to show him the scope of my “bad” in the fullness of its butchery, hoping only that he wouldn’t make too much fun of me as he said the words himself.  Part of me now likes to think Chuck was wise enough to anticipate just such a mishap,, and that’s why he gave me a stem that once had such an enormous tenon in the first place.  The next day, with the shameful proof of my ineptitude tucked deep within my coat pocket, I ventured into the tobacco shop and spotted Chuck at the far end of the long counter that ran to the back on the right side.  He glanced up from what he was doing at the sound of the door chime, saw who it was and continued working.  He knew my routine, which I followed then with nervous mind a jangle, walking to the sitting area and setting down my heavy tote bag filled with a variety of excellent pipes and tobaccos from which I could sit a while and choose at leisure.  Taking my time to claim my favorite comfortable cushioned chair – the only one with a full view of the store because it panders to my life-long discomfort of having my back to a room – I was all-too-soon settled in and made my way with the vile stem in hand to Chuck.

Of course when I displayed to him the mess I had made, Chuck was as gracious as ever, which is not to say lacking in some bemused gruffness, but I was put at ease with a wonderful combination of relief and kinship when he did his best, I have no doubt, not to break into outward laughter.  He could read my face despite its poker table nature and allowed only a genuine grin of appropriate amusement to show on his.  The grin said at once, without a word yet spoken, “Been there…done that,” even if not with the same aptitude.

I sit here at my laptop as I near the conclusion of the tumultuous account of the tale of two jichimus, smoking a soothing bowl of Rattray’s Brown Clunee in my own Chinese Phoenix Wood.  (I like the mythological sound of that better.)  The second bowl needing only the stem and a final quick wheel buff by Chuck, I managed a passable job on the church stem – at least enough to make it fit the shank snugly – and polished the Lucite to a fine luster.

jichimu13

Robert Boughton jichimu restore. Photo © Robert M. Boughton.

When the time came to present the pipe to Ashley at our weekly meeting, which she attended knowing something was up but having no idea what it was, I recommended upon giving it to her  that she might consider finding a replacement stem, or at least arranging to have it curved.  But she filled the bowl in delight and lit it up for the first time, and the look of satisfaction and pleasure on her face were all I needed to put the project to bed.  She insists to this day that the jichimu is one of the coolest, smoothest smoking pipes she owns.

Conclusion

The end of any serious undertaking tends to be followed by a period of time that can be described as both exhilarating to a degree but more of a let-down over-all, and the only cure for this edgy malaise is a new game plan to replace the last.  The conclusion of the jichimu restoration project, not the least of which is marked for me by this writing,leaves not an actual dearth in my life except for the heartfelt kind, for I found in my meager contributions to it a new calling of which I had only imagined I might one day have a genuine calling and now know the suspicion, or dream, is more than that.  As I suggested earlier in this account, I have long known the pleasure of using my hands in woodwork, in particular the simple tactile nature of wood itself, and of taking apart such things as old furniture and stripping off the old paint and varnish to be improved – after attentive, deliberate, meticulous preparation – with fresh new replacements.  Now, on the verge of acquiring an electric buffing wheel because the time has clearly come to stop passing off that final touch, I know I have a future in pipe restoration if not their actual making.

In my near future, therefore, I see several tasks I have been procrastinating, most of them remaining literary in nature but the third having a distinctly different approach to woodworking than pipe restoration: a very old padded rocking chair that has remained unused outside, over time collecting dirt and losing more and more of its stuffing, its fine brass screws, nuts, washers and bolts tarnishing, its lack of attention and use leaving it, as it were, almost lonely – if indeed a natural born writer with a flair for woodwork could personify an old rocker.

But I expect I will have to start my own blog to tell the tale of that restoration.

A Little Czech System Pipe Reborn


I had this little Czechoslovakian rusticated bowl in my box. I decided it was the day to work on it so I took it from the box and gave it the once over to see what needed to be done. The finish was a bit spotty, and the shiny varnish on it was peeling so I dropped it in an alcohol bath to try to break down the finish. The next three photos show the bowl after I had taken it out of the bath. While it was still wet I used a wire brush and some Everclear to scrub the surface of the bowl to remove the flaking finish and the varnish coat. I also topped the bowl to remove the damage that had been done to it from tapping it out. The fourth picture below shows the topped bowl

ImageImageImageImage

I went through my can of stems to find one that would fit. I had a nice p-lip style stem stamped WDC Wellington that came from a pipe of similar size and shape. I was able to sand it a little to make a good fit tight fit to the shank. I cleaned up the stem with micromesh sanding pads 1500-12,000 and then gave the stem a polish with Maguiar’s. I sanded it a final time with the 12,000 grit micromesh before wiping it down with Obsidian Oil. The two photos below show the finished stem.

ImageImage

I restained the bowl with dark brown aniline stain, flamed it, restained and flamed it a second time. The restained pipe is shown in the next two photos. Once it was dry I took it to the buffer and buffed the stem and the bowl with White Diamond.

ImageImage

 

I brought the pipe back to the work table and gave it multiple coats of the Halcyon II wax as I find it does a great job giving rusticated pipes a nice sheen. I also coated the stem with carnauba wax and hand buffed the entire pipe with a shoe shine brush. The hand buffing brought out a nice shine on the pipe.

ImageImageImageImage